Lanier CP-282 manual Material Safety Data Sheet, Emergency Telephone, Hazards Identification

Lanier Worldwide, Inc.

2300 Parklake Drive, NE

Atlanta, GA USA 30345-2979

MATERIAL SAFETY DATA SHEET

Emergency Telephone: 800-526-4371

Section 1: Chemical Product and Company Information

Identity:	TDC10 Black Toner Cartridge	MSDS No.	CP- 282
Product ID:	117-0191	Issued:	06/15/2004
Synonyms		Supersedes:	05/08/1995
	TDC-10 Toner Developer Cartridge	Date:	06/15/2004
& Common	Black Toner for	Prepared by:	EH&S Department 770-496-9500
Names:	Lanier 6610	Approved by:	Larry Choskey, Manager, CEH&S
Uses:		European	Walter Fricke, Manager, Safety &
	Lanier 6610 Copier	Contact:	Environment,
Chemical			Lanier Worldwide, Inc.
			Im Taubental D-41468 Neuss,
Formula:	Mixture		Germany +49-2131-387-177

Section 2: Composition / Information on Ingredients

Toner Component	Percent	CAS No.	Exposure Limits	Source
Styrene acrylate copolymer	92	25767-47-9	Not listed	n/a
Carbon black	4	1333-86-4	3.5mg/m3	OSHA PEL
			3.5mg/m3	ACGIH TWA
Organic pigment	4	8005-02-5	Not listed	N/a
Developer Component	93.5	7439-89-6	Not listed	N/a
Iron powder
Carbon black	0.3	1333-86-4	3.5mg/m3	OSHA PEL
Difluorethylene polymer	0.5	24937-79-9	3.5mg/m3	ACGIH TWA
			Not listed	N/a
Styrene acrylate copolymer	5.5	25767-47-9	Not listed	n/a
Organic pigment	0.2	8005-02-5	Not listed	N/a

*PEL as the product: 15mg/m3 (total dust), 5mg/m3 (respirable dust)

*TLV as the product: 10mg/m3 (total dust), 5mg/m3 (respirable dust)

	Section 3: Hazards Identification
HMIS Rating:	HEALTH = 1
FLAMMABILITY = 1
REACTIVITY = 0	SPECIAL = none

Health Hazards (Acute, Chronic, Immediate and Potential): Minimum irritation to respiratory tract may occur as with exposure to any non-toxic dust. May cause gasping if inhaled. Inhalation should be avoided. May cause temporary eye discomfort.

Health Hazards of Long Term exposure (Chronic): Prolonged inhalation of excessive dust may cause lung damage. It is attributed to “lung overloading”, a generic response to excessive amounts of any dust retained in the lungs for a prolonged interval. Use of this product, as intended, does not result in inhalation of excessive dust.

Carcinogenicity: Carbon Black was reclassified as a Group 2B by the IARC in 1996 based upon the result of only the inhalation study in rats. However, there was not observed the incidence of tumors on the test results on dermal or oral studies. Also, 2-years inhalation study using a typical toner containing carbon black showed no association between toner exposure and animal tumors.

Section 4: First Aid Measures

Inhalation:	Gargle with water. Remove to fresh air if effects	Eye Contact:	In case of contact, immediately flush eyes
	occur. Get medical attention if needed.		with water for 15 minutes. Get medical
Skin Contact:	Wash with soap and water.	Ingestion:	attention if needed.
			Dilute stomach contents with several
			glasses of water. Get medical attention.
	Section 5: Fire Fighting Measures
Suitable extinguishing media: CO2, dry chemical, foam or water.		Extinguishing media which may not be used for safety
		reasons: none
Special protective equipment for fire fighters: none
UEL: n/a	LEL: n/a

y o u r d o c u m e n t m a n a g e m e n t p a r t n e r