Little Wonder TRS-20 manual Table Of Contents, Introduction, Thank You, Read This Manual, Warranty

TABLE OF CONTENTS

INTRODUCTION	2
Thank You	2
Read This Manual	2
Warranty	2
Measurements	2
Serial Numbers	2
Ordering Parts	2
Directions	2
Pre-Delivery Check List	3
Delivery Check List	3
Owner’s Record	3
SAFETY PRECAUTIONS	4
Training	4
Preparation Safety	4
Engine Safety	4
Operational Safety	4
OPERATION	5
Preparation	5
Starting Engine	5
Transporting TURF RAKE/ TURF SEEDER	5
Operating TURF RAKE/ TURF SEEDER	5
OPTIONAL BLADE ASSEMBLIES	6
Changing Blade Assemblies	6
Replacing Shaft Assembly Only	6
Recommended Height Adjustments	6

INTRODUCTION

THANK YOU

Thank you for purchasing a CLASSEN TRS-20/ TSS-20.

READ THIS MANUAL

Read this manual carefully in its entirety. It contains assembly, operating, maintenance, adjustment instructions and a parts list for your TRS-20/TSS-20. By following the operating and maintenance instructions you will prolong the life of your equipment and maintain its maximum efficiency. Failure to do so could result in personal injury or equipment damage. This manual should be considered a permanent part of your TRS-20/TSS-20 and should remain with it if you sell it.

WARRANTY

Refer to last page.

GENERAL MAINTENANCE	8
TURF RAKE/ TURF SEEDER Maintenance	8
Engine Maintenance	8
MACHINE STORAGE	8
Storing TURF RAKE/ TURF SEEDER	8
Operation After Extended Storage	8
CARE FOR HYDRAULIC SYSTEM	9
PARTS MAIN FRAME ASSEMBLY	10
PARTS SELF PROPELLED ASSEMBLY ....11
PARTS HANDLE ASSEMBLY	12
SEEDER/MULTIPURPOSE
BLADE ASSEMBLY	13
SLICER BLADE ASSEMBLY	13
SEED BOX ASSEMBLY	14
SEEDER TIRE SCRAPE INSTALLATION 15
SEED BOX INSTALLATION	15
SAFETY DECALS	16
NOTES	17
WARRANTY	18

MEASUREMENTS

U.S. Units of measure are used in this manual.

SERIAL NUMBERS

Write frame and engine serial numbers, plus model numbers in “Owner’s Record” section below. You may need these numbers when you order parts. The serial number sticker plate is located near the left rear corner of the TRS-20/TSS-20 frame.

ORDERING PARTS

When ordering parts, always give the serial number and model of your TRS-20/TSS-20 as well as the quantity, part number and description of the part needed.

DIRECTIONS

“Right Hand” and “Left Hand” sides of the TRS-20/TSS-20 are determined by facing the “back” of the unit as you would operate the machine.

2