WIRING DIAGRAM - 240 VOLT
Wiring diagrams are provided here for reference purposes only. This information is also provided on schematics attached directly to the appliance on the left side.
CAUTION: LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING CONTROLS. WIRING ERRORS CAN CAUSE IMPROPER AND DAN- GEROUS APPLIANCE OPERATION.
L1 = BLACK (POWER)
L2 = BLACK (POWER) G = GREEN (GROUND) N = WHITE (COMMON)
N1 = WHITE (COMMON)
N2 = WHITE (COMMON)
Outside Switches |
|
|
|
|
|
|
|
|
|
|
|
|
| |
Wall Switch | Wall Thermostat | |||||||||||||
| ||||||||||||||
| (power on/off) |
|
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Control Panel | Control Panel | Control Panel |
Heater On/Off | (power on/off) | Flame / Ember |
Switch |
| On/Off Switch |
GROUND
MAIN POWER
N
L2
N
N2
L2
GROUND |
|
|
|
| |
Light (L) |
| |
|
| |
Flame Motor (L) |
| |
|
| |
Fan Motor (L) |
| |
|
| |
Heater 2 (L) | Relay 1 | |
Heater 1 (L) | Relay 2 | |
|
|
| SIP6 | ||
| |||
REMOTE SIP2 | SIP4 | SIP3 | TEM. |
Circuit
Board
|
| SIP13 | SIP11 |
|
|
|
|
| |||
|
|
| |||
|
|
| |||
|
|
|
|
| SIP7 |
Transformer
HOME POWER
SUPPLY
240 V AC.
Figure 21
L1
N1
L1
t104° C t90°C |
Temperature Sensor Remote Sensor
WIRING - 240 VOLT |
|
|
|
|
|
| |
See Power Supply Specifi- | N |
| WHITE | N |
|
| |
cations on Page 3. |
|
|
|
| |||
|
|
|
|
|
| ||
| L1 | 120 V AC. | BLACK | L1 |
|
| |
|
|
|
|
| |||
HOME POWER SUPPLY |
| 120 V AC. | ORANGE | L2 | FIREPLACE WIRE | ||
L2 | HARNESS | ||||||
|
| ||||||
240 V AC. |
|
| BLUE | N1 |
|
| |
120V (L1) + 120V (L2) = 240V |
|
|
|
| |||
|
|
|
|
|
| ||
|
|
| BLUE | N2 |
|
| |
| GROUND | YELLOW AND GREEN | GROUND |
|
| ||
|
|
|
|
| |||
|
| 240 V 3000W |
|
|
|
| |
Figure 22 |
|
|
|
|
|
| |
|
|
|
|
|
|
| |
|
| WARNING |
|
|
|
| |
|
| ||||||
Do not install or operate this fireplace through a switch wired in the 120 V AC or 240 V AC circuits. The only approved |
| ||||||
wiring for a switch is through the low voltage circuit (24 V AC) as shown on Page 14. |
|
|
| ||||
|
| NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. |
|
| 11 |