SECTION 7: OFF SEASON STORAGE
If the unit will be stored for an extended time,
1.Drain all fuel from the fuel tank into a container. Do not use fuel that has been stored for more than 60 days. Dispose of the old fuel in accordance to local regulations.
2.Start the engine and allow it to run until it stalls. This ensures that all fuel has been drained from the carburetor.
3.Allow the engine to cool. Remove the spark plug and put 1 oz. (30 ml) of high quality motor oil into the cylinder. Pull the starter rope slowly to distribute the oil. Reinstall the spark plug.
NOTE: Remove the spark plug and drain all of the oil from the cylinder before attempting to start the unit after storage.
4.Thoroughly clean the unit and inspect for any loose or damaged parts. Repair or replace damaged parts and tighten loose screws, nuts or bolts.
5.Wipe the tines with an oiled rag to prevent rust. The unit is ready for storage.
•Never store the unit with fuel in the tank where fumes may reach an open flame or spark.
•Allow the engine to cool before storing.
•Store the unit in a locked up area to prevent unauthorized use or damage.
•Store the unit in a dry, well ventilated area. Do not store next to corrosive materials, such a fertilizer.
•Store the unit out of the reach of children.
SECTION 8: TROUBLE SHOOTING GUIDE
| Trouble |
| Possible Cause(s) |
| Corrective Action | |||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| ENGINE WILL NOT START | On/Off Stop Control in the STOP | Turn the On/Off Stop Control to START | |||||
|
|
|
| position |
|
|
|
|
|
|
|
| Empty fuel tank |
|
| Fill fuel tank |
|
|
|
|
| Primer bulb wasn't pressed enough |
|
| Press primer bulb fully and slowly |
|
|
|
|
|
|
|
| times |
|
|
|
|
| Engine flooded |
|
| Use starting procedure with choke |
|
|
|
|
|
|
|
| control in the RUN position |
|
|
|
|
| Old or improperly mixed fuel |
|
| Drain fuel tank / Add fresh fuel mixture |
|
|
|
|
| Fouled spark plug |
|
| Replace or clean the spark plug |
|
|
|
|
|
|
|
|
|
|
| ENGINE WILL NOT IDLE |
|
| Air Filter is Plugged |
|
| Replace or clean the air filter |
|
|
|
|
| Old or improperly mixed fuel |
|
| Drain fuel tank / Add fresh fuel mixture |
|
|
|
|
| Improper carburetor adjustment |
|
| Refer to MAKING ADJUSTMENTS, |
|
|
|
|
|
|
|
| Section 5. |
|
|
|
|
|
|
|
|
|
|
| ENGINE WILL NOT |
|
| Old or improperly mixed fuel |
|
| Drain fuel tank / Add fresh fuel mixture |
|
| ACCELERATE |
|
| Improper carburetor adjustment |
|
| Refer to MAKING ADJUSTMENTS, |
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
| Section 5. |
|
|
|
|
|
|
|
|
|
|
| ENGINE LACKS POWER |
|
| Old or improperly mixed fuel |
|
| Drain fuel tank / Add fresh fuel mixture |
|
| OR STALLS WHEN UNDER |
|
| Improper carburetor adjustment |
|
| Refer to MAKING ADJUSTMENTS, |
|
| LOAD |
|
|
|
|
| ||
|
|
|
|
|
| Section 5. |
| |
|
|
|
|
|
|
|
| |
|
|
|
| Cultivator tines bound with dirt or |
|
| Stop the unit, switch the On/Off Stop |
|
|
|
|
| grass |
|
| Control to STOP, clean and remove |
|
|
| |||||||
|
|
|
|
|
|
| any debris binding the tines |
|
|
|
|
|
| ||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
15