l
PAGE 20 — MVC-40G PLATE COMPACTOR — OPERATION & PARTS MANUAL — REV. #4 (06/06/07)
Inspection and Maintenance Service Tables.
1. To make sure your plate compactor is always in good
working condition before using, carry out the maintenance
inspection in accordance with Tables 5 through 7.
MVC-40G — MAINTENANCE
z

Check for leakage of fuel or oil.

z

Remove soil and clean the bottom of compaction plate.

z
Check engine oil, see page 15.
z

Check for loose screws including tightness. See Table 7

below (tightening torque ), for retightening:

Daily Service
ENGINE OIL
1. Drain the engine oil when the oil is
warm
as shown in
Figure 20.
2. Remove the oil drain bolt and sealing washer and allow
the oil to drain into a suitable container.
3. Replace engine oil with recommended type oil as listed
in Table 4. Engine oil capacity is .317 quarts (.3 liters). DO
NOT overfill.
4. Install drain bolt with sealing washer and tighten se-
curely.
Inspection and other services should
always
be carried out
on hard and level ground with the engine shut down.

CAUTION - Inspection

These inspection intervals are for operation under normal
conditions. Adjust your inspection intervals based on the
number of hours plate compactor is in use, and particular
working conditions.

CAUTION - Inspection Intervals

CAUTION - Inspection Intervals

Fuel piping and connections should be replaced every 2
years.
ECNANETNIAMENIGNE.6elbaT
)3(NOITPIRCSEDNOITAREPOEROFEB
TSRIF
HTNOM
RO
.SRH01
YREVE
SHTNOM3
RO
.SRH52
YREVE
SHTNOM6
RO
.SRH05
YREVE
RAEY
RO
.SRH0
01
YREVE
SRAEY2
RO
.SRH002
liOenignE
KCEHCX
EGNAHCX
renaelCriA
KCEHCX
EGNAHC)1(X
stloB&stuNllA fInethgit-eR
yrasseceN X
gulPkrapS
NAELC-KCEHCX
ECALPER X
sniFgnilooCKCEHCX
retserrAkrapSNAELC X
knaTleuFNAELC X
retliFleuFKCEHC X
deepSeldITSUJ
DA-KCEHC )2(X
ecnaraelCevlaVTSUJDA-KCEHC )2(X
senilleuFKCEHC )2()yrassecenfiecalper(sraey2yrevE
nidesunehwylt
neuqerferomecivreS)1( YTSUD .saera
yllacinahcemeradnaslootreporpehtevahuoysselnu,relaedcivresruoyybdeciv
resebdluohssmetiesehT)2(
serudecorpecivresroflaunaMNIBORehtotrefeR.tneiciforp
.slavretniecnanetniamrepo
rpenimretedotnoitarepofosruohgol,esulaicremmocroF)3(
.7ELBAT
retemaiD)mc/gk.ni(EUQROTGNINETHGIT
lairetaM mm6 mm8 mm01 mm21 mm41 mm61 mm81 mm02
T4 07 051 003 005 057 001,1 004,1 000,2
T8-6 001 052 005 008 003,1 000,2 007,2 008,3
T11 051 004 008 002,1 000,2 009,2 002,4 006,5
* )mm01(007~056)mm8(053~003)mm6(001
)munimulafositrap-retnuocesacnI(*
)dednahthgirllaeraenihcamsihthtiwesunisdaerhT(
,tlobhcaenodekramsilairetamfoytilauqdnalairetaM
.wercsdna

G04-CVM.5ELBATNOITCEPSNIENIHCAM

METI FOSRUOH
NOITAREPO SKRAMER
straPdegamaD sruoh8yrevE
)yadyreve(
swercStsoLroesooL sruoh8yrevE
)yadyreve(
gni
llortnoCfonoitcnuF
traPmetsyS
sruoh8yrevE
)yadyreve(
kcehCliOrotarbiVsruoh001yrevE61egapeeS
liOrotarbiV
tneme
calpeR sruoh003yrevE12egapeeS
kcehC)hctulc(tleb-Vsruoh002yrevE12egapeeS