|
| TROUBLESHOOTING | |
|
|
| |
| Table 7. Engine Troubleshooting | ||
|
|
| |
Symptom | Possible Cause | Solution | |
| Spark plug bridging? | Check gap, insulation or replace spark plug. | |
|
|
| |
Diffi cult to start. Fuel is | Carbon deposit on spark plug? | Clean or replace spark plug. | |
available but no SPARK | Short circuit due to defi cient spark plug | Check spark plug insulation. Replace if | |
at spark plug. | insulation? | worn. | |
|
|
| |
| Improper spark plug gap? | Set to proper gap. | |
|
|
| |
| ON/OFF switch is shorted? | Check switch wiring. Replace switch. | |
Diffi cult to start. Fuel is | Ignition coil defective? | Replace ignition coil. | |
|
| ||
available and SPARK | Improper spark gap, points dirty? | Set correct spark gap and clean points. | |
is present at the spark |
|
| |
Condenser insulation worn or short | Replace condenser. | ||
plug. | |||
circuiting? | |||
|
| ||
|
|
| |
| Spark plug wire broken or short circuiting? | Replace defective spark plug wiring. | |
|
|
| |
Diffi cult to start. Fuel | Wrong fuel type? | Flush fuel system and replace with correct | |
is available, SPARK is | type of fuel. | ||
| |||
present at the spark | Water or dust in fuel system? | Flush fuel system. | |
plug and compression | |||
|
| ||
Air cleaner dirty? | Clean or replace air cleaner. | ||
is normal. | |||
| Suction/exhaust valve stuck or protruded? | Reseat valves. | |
Diffi cult to start. Fuel |
|
| |
Piston ring and/or cylinder worn? | Replace piston rings or piston. | ||
is available, SPARK is | |||
|
| ||
Cylinder head and/or spark plug not |
| ||
present at the spark | Torque cylinder head bolts and spark plug. | ||
tightened properly? | |||
plug and compression |
| ||
|
| ||
is low. | Head gasket and/or spark plug gasket | Replace head and spark plug gaskets. | |
| damaged? | ||
|
| ||
|
|
| |
| Fuel not available in fuel tank? | Fill with correct type of fuel. | |
| Fuel cock does not open properly? | Apply lubricant to loosen fuel cock lever. | |
No fuel present at | Replace if necessary. | ||
| |||
|
| ||
carburetor. | Fuel fi lter clogged? | Replace fuel fi lter. | |
|
|
| |
| Fuel tank cap breather hole clogged? | Clean or replace fuel tank cap. | |
|
|
| |
| Air in fuel line? | Bleed fuel line | |
|
|
| |
Weak in power. | Air cleaner dirty? | Clean or replace air cleaner. | |
Compression is proper | Improper level in carburetor? | Check fl oat adjustment. Rebuild carburetor. | |
and does not misfi re. |
|
| |
Defective spark plug? | Clean or replace spark plug. | ||
| |||
|
|
| |
PAGE 24 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09)
