TROUBLESHOOTING 
| Problem | Possible Causes | Possible Remedies |
| ||
| Voltage too low. | a) | Engine speed too slow. | a) | Increase tractor RPMs. |
|
|
|
|
| b) | Reduce the load. (See Load |
|
|
| b) | Generator is overloaded. | Application section of this manual.) |
| |
|
|
|
|
|
|
|
| Circuit breaker trips. | a) | Defective load connected to generator. | a) | Disconnect load. |
|
|
| b) | Defective receptacle. | b) | Replace receptacle. |
|
|
| c) | Generator overloaded. | c) | Reduce the load. (See Load |
|
|
|
|
| Application section of this manual.) |
| |
|
| d) | Defective circuit breaker. | d) | Contact Customer Service for the |
|
|
|
|
| nearest service center. |
| |
| Voltage too high. | a) | Engine speed too high. | a) | Contact Customer Service for the |
|
|
|
|
| nearest service center. |
| |
| Generator overheating. | a) | Generator is overloaded. | a) | Reduce the load. (See Load |
|
|
|
|
| Application section of this manual.) |
| |
|
| b) | Insufficient ventilation. | b) | Make sure there is at least 3 feet of |
|
|
|
|
| clearance on all sides of generator. |
| |
| No output voltage. | a) | Defective load connected to generator. | a) | Disconnect load. |
|
|
| b) | Broken or loose wire. | b) | Replace wire. |
|
|
|
|
| c) | Replace receptacle. |
|
|
| c) | Defective receptacle. | d) | Contact Customer Service for the |
|
|
| d) | Defective stator. | nearest service center. |
| |
|
|
|
| e) | Contact Customer Service for the |
|
|
| e) | Defective rotor. | nearest service center. |
| |
|
|
|
| f) | Contact Customer Service for the |
|
|
| f) | Defective capacitor. | nearest service center. |
| |
|
|
|
| g) | Contact Customer Service for the |
|
|
| g) | Defective circuit breaker. | nearest service center. |
| |
|
|
|
| h) | Increase tractor RPMs. |
|
|
| h) | Engine speed too slow. | I) | Engage PTO. |
|
|
| I) | PTO not engaged. | j) | Contact Customer Service for the |
|
|
| j) Gear box is malfunctioning. | nearest service center. |
| ||
| Excessive gear box | a) | Defective bearing. | a) | Contact Customer Service for the |
|
| noise. |
|
| nearest service center. |
| |
|
| b) | Defective gear. | b) | Contact Customer Service for the |
|
|
|
|
| nearest service center. |
| |
|
| c) | No or low gear oil. | c) | Fill gear box to oil level sight. |
|
|
| d) | PTO driveline is operating at an angle of | d) | Reposition the tractor or generator so |
|
|
| greater than 15°. | the angle is reduced to less than 15° both |
| ||
|
|
|
| vertically and horizontally. |
| |
|
| e) | Unsynchronized PTO driveline. | e) | Disassemble PTO driveline and |
|
|
|
|
| reassemble with CV joints synchronized. |
| |
9
