North Star 8000 PPG owner manual Generator Features, Introduction

GENERATOR FEATURES

Reference 1 - Circuit Breakers. This portable single phase generator has 1, 15 amp (A) 2, 20A, and 2, 30A push to reset circuit breakers to protect against electrical overloads.

Reference 2 - 120/240V Receptacle. The locking device is a 120/240V 30A NEMA L14-30R receptacle. This receptacle accepts a NEMA plug number L14- 30P. Use this receptacle if installing a transfer switch, which is compatible with a Gentran transfer switch, item #16412.

ALWAYS use grounded male plugs. The neutral line of the generator is mechanically grounded to the frame. Matching NEMA male plugs must always be used.

WARNING Contact a licensed electrician to wire electrical plugs and/or cord-sets. Improper wiring could result in a fire or electrical shock.

Reference 3 - Grounding Post. Ground the generator via the grounding post, to a copper pipe or rod that is driven into moist soil.

Reference 4 - 120V Receptacle. The second duplex is a 120V 20A straight blade receptacle, National Electrical Manufacturer’s Association (NEMA) number 5-20R. This receptacle accepts NEMA plug numbers 5-15P and 5-20P. Each receptacle on this duplex is capable of drawing 20A.

Reference 5 - 120V Receptacle. The generator has a control panel with two duplex (two receptacles in

acommon housing) receptacles. The one duplex is a 120 volt (V) 15 amp (A) straight blade receptacle, National Electrical Manufacturer’s Association (NEMA) number 5-15R. This receptacle accepts NEMA plug number 5-15P. The duplex is capable of drawing 15A out of either receptacle or a combination of both.

Reference 6 - Oil Drain Plug. Refer to your Honda engine manual for oil change recommendations.

Reference 7 - Engine Stop Switch. The red engine stop switch is located on the engine. Always locate this switch and be familiar with its location before operating the generator.

Reference 8 - Starting/Stopping Instructions. Reference 9 - Air Cleaner. Refer to your Honda

engine manual for air cleaner care.

Reference 10 - Super Silent Muffler. 4 dB less than Honda’s standard muffler.

Reference 11 - Gas Cap with Gauge. The gas cap is extra large, creating a large hole for refilling and a comfortable grip. You can always monitor the fuel level without removing the cap by using the fuel level indicator built into the gas cap.

Reference 12 - 6.5 Gallon Gas Tank. Large tank allows for extended run capabilities. Always allow room for gasoline expansion by not filling the gas tank completely full.

Reference 13 - Generator Head. The electricity producing part of the generator.

Reference 14 - Vibration Isolation Mounts. The engine and generator are mounted on rubber cylinders that absorb most of the engine vibration. This feature eliminates the tendency of the machine to “walk” which is common in engine powered equipment.

Reference 15 - Recoil. Grasp firmly when

starting engine.

Reference 16 – Fuel Valve Lever. The generator

tank has an ON-OFF valve mounted underneath the tank. Always keep this valve closed when the generator is not in use.

Reference 17 - Choke Lever. Used during cold

starts. Refer to the starting/stopping instructions and the Honda engine manual for usage.

Low Oil Shutdown. The Honda engine is protected against damage resulting from low oil level. As the oil falls below the safe level, the engine automatically shuts off (the engine stop switch remains in the on position). The engine will not start until the oil is refilled to above the safe level.

INTRODUCTION

Before starting your generator, thoroughly study the instructions and cautions in this manual to assure you are fully acquainted with the operation of all components of this generator. Proper preparation, operation and maintenance will result in operator safety, best performance and long life of the generator. For detailed engine operation and maintenance always refer to the Honda engine owner’s manual furnished with the generator (Honda refers to the 13 Hp engine as a GX390).

NorthStar is constantly improving its products. The specifications outlined herein are subject to change without prior notice or obligation. The purchaser and/or user shall assume liability of any modification and/or alterations on this equipment from original design and manufacture.

Before using, the user shall determine the suitability of this product for its intended use and assumes liability therein.

4