ENGINE
SRemove spark plug and pour 1 teaspoon of 40:1,
starter rope 8 to 10 times to distribute oil.
SReplace spark plug with new one of recom-
mended type and heat range (see RE- PLACE SPARK PLUG section).
SClean air filter.
S Check entire unit for loose screws, nuts, and bolts. Replace any damaged, broken, or worn parts.
SAt the beginning of the next season, use only fresh fuel having the proper gasoline to oil ratio.
TROUBLESHOOTING TABLE
OTHER
SDo not store gasoline from one season to another.
SReplace your gasoline can if it starts to rust.
NEED ASSISTANCE?
NEED ASSISTANCE?
Call
NEED SERVICE PARTS?
Contact your dealer.
WARNING: Always stop unit and disconnect spark plug before performing all of the recommended remedies below except remedies that require operation of the unit.
TROUBLE | CAUSE | REMEDY | ||
Engine will not | 1. | ON/OFF switch in the | 1. Move ON/OFF switch to the ON | |
start. |
| OFF position. |
| position. |
| 2. | Engine flooded. | 2. See “Starting a Flooded Engine” | |
| 3. | Fuel tank empty. |
| in Operation Section. |
| 3. Fill tank with correct fuel mixture. | |||
| 4. | Spark plug not firing. | 4. Install new spark plug. | |
| 5. | Fuel not reaching | 5. Check for dirty fuel filter; replace. | |
|
| carburetor. |
| Check for kinked or split fuel line; |
| 6. | Compression low. |
| repair or replace. |
| 6. Contact an authorized service dealer. | |||
Engine will | 1. Carburetor requires | 1. | See “Carburetor Adjustment” in | |
not idle |
| adjustment. |
| Service and Adjustments Section. |
properly. | 2. Crankshaft seals worn. | 2. | Contact an authorized service dealer. | |
| 3. Compression low. | 3. | Contact an authorized service dealer. | |
Engine will not | 1. | Air filter dirty. | 1. | Clean or replace air filter. |
accelerate, | 2. Spark plug fouled. | 2. | Clean or replace plug | |
lacks power, | 3. | Carburetor requires |
| and regap. |
or dies under | 3. | Contact an authorized service dealer. | ||
a load. | 4. | adjustment. | 4. | Contact an authorized service dealer. |
| Carbon | |||
|
| muffler outlet screen. |
|
|
| 5. | Compression low. | 5. | Contact an authorized service dealer. |
Engine | 1. Choke partially on. | 1. | Adjust choke. | |
smokes | 2. Fuel mixture incorrect. | 2. | Empty fuel tank and refill with | |
excessively. | 3. | Air filter dirty. | 3. | correct fuel mixture. |
| Clean or replace air filter. | |||
| 4. Carburetor requires | 4. | Contact an authorized service dealer. | |
|
| adjustment. |
|
|
Engine runs | 1. Fuel mixture incorrect. | 1. | See “Fueling Engine” in Operation | |
hot. |
|
|
| section. |
| 2. Spark plug incorrect. | 2. | Replace with correct spark plug. | |
| 3. Carburetor requires | 3. | Contact an authorized service dealer. | |
|
| adjustment. | 4. | Contact an authorized service dealer. |
| 4. Carbon | |||
|
| muffler outlet screen. |
|
|