TROU LESHOOTJNG POINTS
PROBLEM | CAUSE | CORRECTION |
| i |
|
Will not start
Hard to start
Engine will not turn over
Engine clicks but will not start
Loss of power
tOut of fuel
2Engine not"CHOKED" property
3Engine flooded
4Badsparkplug
5r Dttty air filter,
6Dirty fuel filter, 7, Water in fuel
8.Loose or damaged wiring
9, Carburetor out of adjustment.
10 Engine valves out of adjustment
1Dirtyair filter 2, Bad spark plug
3, Weak or dead battery
4Dirty fuel filter
5Stale or dirty fuel
6 Loose or damaged wiring,
7 Carburetor outof adjustment
8.Engine valvesout of adjustment
1Clutch/brake pedal not depressed, 2, Attachment clutchis engaged
3.Weakor dead battery 4, Blown fuse
5Corroded battery terminals 6, Loose or damaged wiring 7, Fautty ignition switch.
8, Faulty solenoid or starter
g. Faultyoperator presenceswttch(es),
1 Weakor dead battery,
2, Corroded battery terminals 3, Loose or damagedwldng,
4_ Faulty solenoid or starter.
1, Cutting too much grass/too fast 2, Throttle_n"CHOKE" position.
3, Build.up of grass, leaves and trash under mower 4 Dirty air _ter,
5, Low oil level/dirty oil
6Faulty spark plug
7Dirty fuel filter
8Stale or dirty fuel
9Waterln fuel.
1 Fill fuel tank
2See "TO START ENGINE" In Operation section,
3Wait several minutes before attempting to start
4Replace spark plug
5Clean/replace air filter
6Replace fuel tilter
7Drain fuel tank and carburetor, refill tank with fresh gasoline and replace fuel filter
8Check all wiring,
9See "To Adjust Carburetor" in Service Adjustments section.
t0 Contact an authorized service center/department,
1Clean/replace air filter
2 Replace spark plug
3 Recharge or replace battery
4 Replace fuel filter
5 Drain fuel tank and refill with fresh gasoline
6 Cbeck all wiring
7 See "To Adjust Carburetor" in Service Adjustments section
8 Contact an authorized service center/department
1 Depress clutch/brake pedal
2Disengage attachment clutch, 3, Recharge or replace battery
4Replace fuse
5Clean batteryterminals
6Check all wtdng
7Check/raplace ignition switch,
8Check/raplacesolenoid orstarter,
9, Contactan authorized service center/depertmentr
1Recharge or replace battery_
2Clean battery terminals
3Check all wiring
4Check/replace solenoid or starter,
1, Set In "Higher Cut" position/raducespeed,
2, Adjust throttlecontrol
3 Clean underside ofmowerhousing
4.Cleaniraplace air filter,
5 Check otl leve!/change oil,
6Clean and regap or change spark plug,
7Replace fuel filter.
8Drainfuel tank and refill with fresh gasollne-
9, Drain fuel tank and carburetor, refill tank with fresh gasoline and replace fuel filter,
10 Spark plug wire loose.
11.Dirty engtne air screen/tins,
12Dirty/clogged muffler.
13, Loose or damaged wtrlng, 14, Carburetor out of adjustment
!0 Connect and tighten spark plug wire
11Clean engineair screen/fins-
12Clean/replace muffler,
13Check all wiring,
14, See "To Adjust Carburetor" in Service Adjustments section
| 15 | Engine valves out of adjustment, | 15, | Contact an authorized service centeddepartment, |
Excessive vibration | 1 | Wom, bentorloose blade | 1 | Replace blade Tighten blade bolt, |
| 2 | Bentblade mandrel, | 2 | Replace blade mandrel. |
| 3 | Loose/damaged part(s), | 3 | Tightenloose part(s) Replace damaged parts, |
27
