Section 4 - MAINTENANCE
WARN ING
Allow engine to cool for at least ten minutes before performing service or maintenance. DO NOT smoke near fuel components when performing service or
maintenance. DO NOT perform service and maintenance near an open flame. Wipe off any spilled fuel before starting engine. DO NOT run engine indoors.
4.5ANNUALLY (END OF EACH SEASON)
(Continued from previous Page)
4,5,2. FUEL FILTER
Service fuel filter as instructed below. Turn key to "OFF" position. Engine MUST be stopped and MUST be cold before removing filter. Clamp fuel line to prevent fuel spillage or perform filter change when fuel tank and fuel line are empty.
1.Remove fuel line clamps from fuel filter.
2.Remove fuel lines from filter. Discard filter.
3.Install new fuel filter. IMPORTANT: Some fuel filters are fuel flow directional. Check for arrow that
shows fuel flow direction. Reinstall fuel Iine clamps. See Figure 4.8.
LEFT SIDE OF
MACHINE
CLAMP FUEL LINE
TO PREVENT
REMOVE | LINE | LINE TO | |
PREVENT | |||
|
| ||
CLAMPS |
| SPILLAGE |
FIGURE 4.8
4.6DECK REMOVAL
Move power unit/mower deck to an area where the mower deck is to be disconnected. Turn engine "OFF" and remove key from switch. Remove spark plug wire(s) and secure away from spark plug(s). Move motion control levers to the neutral position. Engage parking brake.
1. Move deck lift lever and set the mower deck to
the highest cutting position. See Figure 4.9.
2.IMPORTANT - STORED ENERGY, Relieve
tension on deck lift assist spring by backing off nut on eyebolt. Failure to relive tension could result in
personal injury. See Figure 4.9.
3. Place a wooden block under the front and rear
edge of the mower deck.
4. Move deck lift lever and set the mower deck to a
lower cutting position until deck rests on wooden blocks. Position the deck to where there is no
tension on the deck hanger chains. See Figure 4.9.
LOWEST CUTTING
POSITION (ALL THE
WAY,)
POSITION DECK LIFT LEVER IN HIGHEST CUTTING
POSITION. PLACE WOODEN BLOCKS UNDER FRONT AND REAR OF DECK, LOWER DECK ONTO BLOCKS
LOOSEN DECK
LIFT ASSIST
FIGURE 4.9
(Continued On Next Page)
18
