General Safety Information | State Industries GP6 50 guide

GENERAL SAFETY INFORMATION

at least 18"(45.7cm) above the floor. This will reduce, but not eliminate, the risk

4

Image 4

State Industries GP6 50 instruction manual General Safety Information

Contents

Printed Whenever maintenance adjustment or service is required197425-005 Approvals Safe INSTALLATION, USE and ServiceImportant Definitions General Safety Information General Safety Information Table of Contents Introduction Installation of Carbon Monoxide Detectors Approved Carbon Monoxide DetectorsSignage Exemptions Replacement Parts and Deliming Products Typical InstallationElbow Access Door Condensate Hose and Drain PAN Mixing Valves Less Severe Burns 2nd & 3rd Degree Locating the NEW Water Heater Facts to Consider About the Location Insulation Blankets Air REQUIREMENTs Unconfined Space Confined SpaceFresh Air Openings For Confined Spaces Outdoor Air Through Two Openings Outdoor AIR Through TWO Vertical Ducts Outdoor AIR Through TWO Horizontal DuctsAIR from Other Indoor Spaces Installing the NEW Water Heater Chemical Vapor CorrosionWater Piping Space Heating and Potable Water System Thermal Expansion Temperature-Pressure Relief ValveValve and Pipe Insulation High Altitude Installation Gas Piping Sediment Traps Filling the Water Heater Vent Pipe Assembly Venting Termination Clearances Sidewall Power Vent Vent Pipe Termination Condensate Planning the Vent SystemBreathing Hazard Carbon Monoxide Gas Installation of Vent System Blower Assembly InstallationVent Terminal INSTALLATION, Sidewall Power Vent Wiring Schematic Figure Sequence of INSTALLATIONS, FigureVent Termination Figure Installation of Vent SYSTEM, Sidewall Installation of Vertical Vent System Vent Attenuation Assembly Installation Vertical VAA Installations Recommended Inch vent Vertical VAA Installations Vent Pipe Preparation Recommended BRUSH* Size for Primer Cement Applications Step B Step EStep F Step GPage Temperature Regulation GAS Control Valve Front View Periodic Maintenance For Your InformationStart UP Conditions Operational Conditions Burner Cleaning Burner Operation and InspectionHousekeeping Anode ROD Inspection Temperature-Pressure Relief Valve Test Draining and FlushingTo Drain the Water Heater Storage Tank To Flush the Water Heater Storage Tank Service Leakage Checkpoints Repair Parts List Trouble Shooting Troubleshooting GuidelinesLED Status Problem Solution LED Status Problem Solution Troubleshooting Guidelines Page ServIce and laBor responsIBIlItY ClaIM procedureCondItIons and eXceptIons LIMItatIon on IMplIed warrantIes Copyright 2010 State Industries, Inc. All rights reserved