Manuals
/
State Industries
/
Household Appliance
/
Water Heater
State Industries
GP6 50
instruction manual
Troubleshooting Guidelines
Models:
GP6 50
1
37
40
40
Download
40 pages
24.74 Kb
33
34
35
36
37
38
39
40
Troubleshooting
Install
Repair Parts List
Maintenance
Vent Pipe Assembly
ClaIM procedure
Burner Cleaning
Temperature Regulation
Safety
Service
Page 37
Image 37
TROUBLESHOOTING GUIDELINES
These guidelines should be utilized by a qualified service agent.
37
Page 36
Page 38
Page 37
Image 37
Page 36
Page 38
Contents
Printed
Whenever maintenance adjustment or service is required
197425-005
Approvals
Safe INSTALLATION, USE and Service
Important Definitions
General Safety Information
General Safety Information
Introduction
Table of Contents
Approved Carbon Monoxide Detectors
Installation of Carbon Monoxide Detectors
Signage
Exemptions
Replacement Parts and Deliming Products
Typical Installation
Elbow Access Door
Condensate Hose and Drain PAN
Less Severe Burns 2nd & 3rd Degree
Mixing Valves
Facts to Consider About the Location
Locating the NEW Water Heater
Air REQUIREMENTs
Insulation Blankets
Confined Space
Unconfined Space
Fresh Air Openings For Confined Spaces
Outdoor Air Through Two Openings
Outdoor AIR Through TWO Vertical Ducts
Outdoor AIR Through TWO Horizontal Ducts
AIR from Other Indoor Spaces
Chemical Vapor Corrosion
Installing the NEW Water Heater
Water Piping
Space Heating and Potable Water System
Thermal Expansion
Temperature-Pressure Relief Valve
Valve and Pipe Insulation
Gas Piping
High Altitude Installation
Filling the Water Heater
Sediment Traps
Venting
Vent Pipe Assembly
Vent Pipe Termination
Termination Clearances Sidewall Power Vent
Condensate
Planning the Vent System
Breathing Hazard Carbon Monoxide Gas
Installation of Vent System
Blower Assembly Installation
Vent Terminal INSTALLATION, Sidewall
Power Vent Wiring Schematic Figure
Sequence of INSTALLATIONS, Figure
Vent Termination Figure
Installation of Vertical Vent System
Installation of Vent SYSTEM, Sidewall
Vertical VAA Installations Recommended
Vent Attenuation Assembly Installation
Inch vent Vertical VAA Installations
Recommended BRUSH* Size for Primer Cement Applications
Vent Pipe Preparation
Step E
Step B
Step F
Step G
Page
GAS Control Valve Front View
Temperature Regulation
For Your Information
Periodic Maintenance
Start UP Conditions
Operational Conditions
Burner Operation and Inspection
Burner Cleaning
Housekeeping
Anode ROD Inspection
Draining and Flushing
Temperature-Pressure Relief Valve Test
To Drain the Water Heater Storage Tank
To Flush the Water Heater Storage Tank
Leakage Checkpoints
Service
Repair Parts List
Trouble Shooting
Troubleshooting Guidelines
LED Status Problem Solution
LED Status Problem Solution
Troubleshooting Guidelines
Page
ClaIM procedure
ServIce and laBor responsIBIlItY
CondItIons and eXceptIons
LIMItatIon on IMplIed warrantIes
Copyright 2010 State Industries, Inc. All rights reserved
Top
Page
Image
Contents
