SOLID FLUE DAMPER INSTALLATION
This unit comes equipped with a solid flue damper which is intended to be installed into the flue collar. The following instructions will help guide you in installing the solid flue damper.
1.Before you connect the 6" flue pipe to the flue collar, place the solid damper inside of the flue collar on an angle to permit the damper to slide between to two stops that are welded into the flue collar.
2.Place the damper rod into the hole on one side of the flue collar, aligning it with the flue damper. Twist the damper rod back and forth as you slide the damper rod through the flue collar and solid damper.
3.Once the damper rod is completely through the flue collar, lock the damper rod into the solid damper by pressing in firmly on the damper rod and twisting. At this point the Damper rod should be able to open and close the solid damper.
NOTE: This unit has been tested with the cast iron stops in the flue collar to meet EPA requirements.
DAMPER ROD
SOLID DAMPER
|
|
|
| A |
|
|
|
|
|
|
| D M |
|
| |||
|
| N |
|
|
| P |
|
|
IR | O |
|
|
| E | |||
|
|
|
| R | ||||
T |
|
|
|
|
|
|
|
|
S |
|
|
|
|
|
|
| C |
A |
|
|
|
|
|
|
| |
C |
|
|
|
|
|
|
| A |
|
|
|
|
|
|
|
| S |
|
|
|
|
|
|
|
| T |
R |
|
|
|
| R | O | I | |
E 6I | H |
| ||||||
| P |
| N C |
|
|
| ||
|
| MAD | N |
|
| |||
|
|
|
|
|
| |||
CABINET BACK
FLUE COLLAR
REPAIR PARTS LIST - MODEL 2931 (SEE PAGE 18)
AUTOMATIC WOOD BURNING CIRCULATOR
| Key No. | Description | Qty. | Part No. |
1 | Fire Grate | 2 | 40076 | |
2 | Ash Pan | 1 | 67444 | |
3 | Base | 1 | 67859 | |
4 | Draft Damper Hinge Pin | 1 | 17200 | |
5 | Draft Damper Frame | 1 | 40075 | |
6 | Draft Control Plate | 1 | 23476 | |
7 | Clip | 2 | 83818 | |
| 8 | Glass Brass Trim (LH/RH) | 2 | 89382 |
9 | Glass Brass Trim (TOP/BOTTOM) | 2 | 89381 | |
10 | Glass Frame | 1 | 68452 | |
11 | Glass Gasket | 66" | 88047 | |
12 | Glass (20 1/2"x12 1/2") | 1 | 89409 | |
13 | Left Half Brick | 1 | 23782 | |
14 | Front Coal Grate | 1 | 40283 | |
| 15 | Flue Collar | 1 | 40343 |
16 | Fire Box Weldment | 1 | 68693 | |
17 | Firebrick Retainer | 1 | 40132 | |
18 | Firebrick | 7 | 89066 | |
19 | Door Hinge Pin | 1 | 83114 | |
20 | Feed Door Assembly | 1 | 67775 | |
21 | Feed Door Rope Gasket | 44" | 88033 | |
22 | Thermostat | 1 | 67743 | |
23 | Thermostat linkage adjustment | 1 | 86191 | |
24 | Door Handle | 2 | 40091 | |
25 | Flat Washer | 1 | 83045 | |
26 | Hex Nut | 2 | 83250 | |
27 | Latch | 1 | 22108 | |
28 | Ash Door Rope Gasket | 29" | 88033 | |
29 | Ash Door | 1 | 67781 | |
30 | Thermostat Knob | 1 | 89687 | |
31 | Front Liner | 1 | 40100 | |
32 | Heat Shield | 1 | 23703 | |
33 | Draft Damper | 1 | 40282 | |
34 | Rear Half Brick | 1 | 23785 | |
35 | Left Top Brick Retainer | 1 | 23145 | |
36 | Second Heat Shield | 1 | 22030 | |
37 | Flue Collar Gasket | 1 | 88032 | |
38 | Air Wash Deflector | 1 | 23547 | |
* | Grate Support | 2 | 22536 | |
* | Corner Key (Brass Trim) | 10 | 89419 | |
* | Blank Key (Brass Trim) | 10 | 89420 | |
39 | Wood Handle | 1 | 89523 | |
40 | Door Hinge Pin | 1 | 23441 | |
41 | Door Latch | 1 | 21047 | |
42 | Latch Spacer | 1 | 21467 | |
43 | Smoke Curtain | 1 | 22090 | |
44 | Heat Shield | 1 | 23474 | |
* | Smoke Curtain Bracket | 2 | 22171 | |
*NOT SHOWN
6 | 19 |
