Manuals / Viking / Kitchen Appliance / Microwave Oven

Viking VMOC205SS, DMOC205SS service manual Packing and Accessories

Models: VMOC205SS DMOC205SS

1 48

Page 46

DMOC205SS
VMOC205SS
1	2	3	4	5	6
PACKING AND ACCESSORIES
A	TRAY HOLDER				A
A					A
				TOP PAD ASSEMBLY
		DOOR PROTECTION SHEET
	4-3 TURNTABLE TRAY
				PLASTIC BAG
B					B
	6-9 OPERATION
	MANUAL
6-14 S/S CLEANING INSTRUCTIONS
	6-15 COOK BOOK
			MICROWAVE OVEN
	4-2 TURNTABLE SUPPORT
C					C
				BOTTOM PAD ASSEMBLY
D		TRAY PACKING FOAM		PACKING CASE	D
D				PACKING CASE	D
			Not replaceable items.
E					E
F					F
G					G
H					H
1	2	3	4	5	6
			44

Page 46

Image 46

Viking VMOC205SS, DMOC205SS service manual Packing and Accessories

Contents

Table of Contents Models DMOC205SS VMOC205SSBefore Servicing DMOC205SS VMOC205SS When the testing is completed Before ServicingRequirements Microwave Measurement Procedure CanadaLeakage test with enclosure installed Leakage test without enclosureMicrowave Measurement Procedure USA Leakage testViking Range Corporation If provided, Vent Hood, Fan assembly, Cooling Fan MotorMicrowave Ovens DMOC205SS VMOC205SS Foreword Description SpecificationHigh MIX. Roast Oven Diagram VMOC205SSDescription of Operating Sequence Power Level P-0 to P-90 CookingOperation OFF ConditionSensor Cooking Condition Convection Cooking ConditionAutomatic MIX Cooking Condition Preheating ConditionCompu BROIL/ Compu ROAST/ Compu Bake Fire Sensing Feature Microwave ModeCompu Defrost Cooking Cooking SequenceSchematic Diagram Figure O-1. Oven Schematic-OFF ConditionFigure O-3. Oven Schematic-Automatic Mix Cooking Condition Description and Function of Components Microwave Cooking Troubleshooting GuideDamper OPEN-CLOSE Mechanism Damper OperationTest Procedure ProblemHigh Voltage Rectifier Test Power Transformer TestHigh Voltage Capacitor Test Monitor Switch Test Procedures Letter Component TestPrimary Interlock Switch and Third Door Switch Test Secondary Interlock System TestHeating Element Test Damper Switch TestChecking Temperature in the Convection Mode Thermistor TestTouch Control Panel Assembly Test Noise Filter TestRelay Test Test Procedures Letter Component Test KEY Unit TestWeight 1ST Stage 2ND Stage 3RD Stage 4TH Stage Level Time Compu Defrost TestChecking the initial sensor cooking condition Steps Occurrence Cause or CorrectionAH Sensor Test Water load cooking testTesting Method for AH Sensor AND/OR Control Unit Checking Control UnitThermistor Touch Control Panel AssemblyDescription of LSI LSIIXA103DRConvection motor driving signal Temperature measurement input Oven ThermistorDigit selection signal Cooling fan motor driving signalTOR Segment data signal Segment data signalsKey strobe signal Absolute Humidity Sensor Circuit Structure of Absolute Humidity SensorServicing Outer Case Removal Component Replacement and Adjustment ProcedurePower Transformer Removal Magnetron RemovalDamper Assembly Removal High Voltage Rectifier Assembly RemovalPositive Lock Connector NO-CASE Type Removal High Voltage Capacitor RemovalThermistor Removal Oven Lamp and Lamp Socket RemovalFAN Motor Removal Heating Element RemovalControl Panel Assembly and Control Unit Removal Power Supply Cord ReplacementControl Unit and KEY Unit After adjustment, check the following Door Replacement and AdjustmentAdjustment RemovalDoor Adjustment Door DisassemblyAfter adjustment, make sure of the following Leakage test Leakage Test with Enclosure Installed Microwave Measurement ProcedurePreparation For Testing RequirementFigure S-1. Pictorial Diagram SFigureControl Panel DIP Cabinet Parts Parts ListElectrical Parts Control Panel PartsMiscellaneous Door PartsScrews Nuts and Washers LX-NZ0029YBE0 Oven and Cabinet Parts Control Panel Parts Door Parts MiscellaneousPacking and Accessories DMOC205SS VMOC205SS Copyright 2004 by Viking

DMOC205SS

PACKING AND ACCESSORIES