6

General Instructions

Operating

The natural gas supply is easy to use and gives you more cooking control than charcoal fuel.

•These instructions will give you the minimum requirements for assembling your

Weber® gas barbecue. Please read the instructions carefully before using your Weber® gas barbecue. Improper assembly can be dangerous.

•Not for use by children.

•If there are local codes that apply to portable gas grills, you will have to conform to them. Installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2 as applicable.

•This Weber® gas barbecue is designed for natural (piped in city) gas only. Do not use liquid propane (LP) bottled gas. The valves, orifices and hose are for natural gas only.

•Do not use with charcoal fuel.

•Check that the area under the control panel and the bottom tray are free from debris that might obstruct the flow of combustion or ventilation air.

Storage

•The gas must be turned off at the natural gas supply when the Weber® gas barbecue is not in use.

•When the Weber® gas barbecue is stored indoors, the gas supply must be disconnected.

•The Weber® gas barbecue should be checked for gas leaks and any obstructions in the burner tubes before using. (See Section: “Maintenance/Annual Maintenance”).

•Check that the areas under the control panel and the slide out bottom tray are free from debris that might obstruct the flow of combustion or ventilation air.

•The Spider /Insect Screens should also be checked for any obstructions. (See

Section: "Maintenance/Annual Maintenance").

mWARNING: Do not use the barbecue within 24 inches (610 mm) of combustible materials. This includes the top, bottom, back or sides of the grill.

mWARNING: The entire cooking box gets hot when in use. Do not leave unattended.

mWARNING: Keep any electrical supply cord and the fuel supply hose away from any heated surface.

mWARNING: Keep the cooking area clear of flammable vapors and liquids, such as gasoline, alcohol, etc., and combustible materials.

Gas Supply Testing

•Disconnect your Weber® gas barbecue when the gas supply is being tested at high pressures. This appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of 1/2 psig (3.5 kPa).

•Turn off your Weber® gas barbecue when the gas supply is being tested at low pressures. This appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at the pressure equal to or less than 1/2 psig (3.5 kPa).

Operating

mWARNING: Only use this barbecue outdoors in a well- ventilated area. Do not use in a garage, building, breezeway or any other enclosed area.

mWARNING: Your Weber® gas barbecue shall not be used under overhead combustible construction.

Grilling Methods

Note: If grill loses heat while cooking refer to the troubleshooting section of this manual.

mWARNING: Do not move the Weber® gas barbecue when operating or while barbecue is hot.

You can adjust the individual main burners as desired. The control settings are Start/ Hi, Medium, Low, or OFF.

Note: The temperature inside your cooking box for the first few uses, while surfaces are still very reflective, may be hotter than those shown in your cookbook. Cooking conditions, such as wind and weather, may require the adjustment of the burner controls to obtain the correct cooking temperatures.

If burners go out during cooking, open lid, turn off all burners and wait five minutes before relighting.

Sear Station™ - Your Weber® gas barbecue includes a sear burner for searing thin meats and fish. The Sear Station™ burner has an on or off control setting that works with the two adjacent main burners. With the sear and adjacent burners you can effectively sear meats while using other cooking areas for cooking with moderate heat.

Preheating - Your Weber® gas barbecue is an energy-efficient appliance. It operates at an economical low BTU rate. To preheat: after lighting, close lid and turn all burners to “START/HI”. Preheating to between 500° and 550° F (260° and 290° C) will take 10 to 15 minutes depending on conditions such as air temperature and wind.

Drippings and grease - The Flavorizer® bars are designed to “smoke” the correct amount of drippings for flavorful cooking. Excess drippings and grease will accumulate in the catch pan under the slide out bottom tray. Disposable foil drip pans are available that fit the catch pan.

mWARNING: Check the bottom tray for grease build-up before each use. Remove excess grease to avoid a grease fire in the slide out bottom tray.

Cleaning

mWARNING: Turn your Weber® gas barbecue off and wait for it to cool before cleaning.

mCAUTION: Do not clean your Flavorizer® bars or cooking grates in a self-cleaning oven.

For availability of replacement cooking grates and Flavorizer® bars contact the Customer Service Representative in your area using the contact information on our website. Log onto www.weber.com®

Outside surfaces - Use a warm soapy water solution to clean, then rinse with water.

mCAUTION: Do not use oven cleaner, abrasive cleansers (kitchen cleansers), cleaners that contain citrus products, or abrasive cleaning pads on barbecue or cart surfaces.

www.weber.com®

Page 5 Page 7
Page 6
Image 6
Weber S-460 manual General Instructions, Storage, Operating Grilling Methods, Cleaning
Page 5 Page 7

S-460 specifications

The Weber S-460 is a premium gas grill that epitomizes both functionality and modern design, making it a top choice for grilling enthusiasts and professionals alike. Known for its robust build and advanced features, the S-460 represents Weber's commitment to quality and performance.

One of the main attractions of the S-460 is its four stainless steel burners, which provide a total of 48,000 BTUs of cooking power. This substantial output ensures quick heating and temperature consistency across the grilling surface. The primary cooking area is spacious, measuring 633 square inches, allowing for ample space to cook multiple items simultaneously. Additionally, it features a 12,000 BTU side burner, perfect for cooking sauces or sides while grilling.

The S-460 is engineered with Weber's exclusive Flavorizer Bars, which not only help to distribute heat evenly but also catch drippings that can create delicious smoke flavor. This innovative design enhances the overall taste of grilled foods, resulting in a sumptuous grilling experience. The integrated smoker box further elevates the grilling possibilities, allowing you to infuse your meals with smoky flavors by using wood chips.

Another key characteristic of the Weber S-460 is its built-in LED lighting. This feature illuminates the control knobs, providing visibility even during evening barbecues. The grill is constructed from high-quality materials, including a durable stainless steel exterior and porcelain-enameled, cast-iron cooking grates that retain heat superbly and ensure even cooking.

Maintaining the S-460 is straightforward thanks to its easy-to-clean grease management system. The removable drip tray collects excess grease, making cleanup after cooking a breeze. The grill's design promotes durability, ensuring that it withstands the elements and the test of time.

In summary, the Weber S-460 is not just a grill; it is a complete grilling solution that combines powerful performance with innovative features. With its spacious cooking area, advanced technologies, and thoughtful design elements, it caters to both novice and experienced grillers. Whether hosting a summer barbecue or preparing a family meal, the Weber S-460 stands ready to deliver exceptional results, creating mouthwatering meals that are sure to impress.
Top Page Image Contents