6
Maintaining 
Your Lawn
Tractor
*Kohler Single Shown
IMPORTANT: Refer to the Engine Operator/Owner Manual packed with your unit for information regarding the quantity and proper weight of motor oil.
Air Cleaner
Service the
Spark Plug(s)
The spark plug(s) should be cleaned and the gap reset once a season. Spark plug replacement is recommended at the start of each mowing season. Refer to the Engine Operator/Owner Manual for correct plug type and gap specifications.
WARNING
Before performing any maintenance, lubrication or repairs, disengage PTO, move shift lever into neutral position, set parking brake, stop engine and remove key to prevent unintended starting.
NOTE: Depending on the engine model found on your tractor, it may be necessary to remove the tractor’s side panel in order to replace the oil filter (if so equipped).
Figure
WARNING: Before performing any maintenance or repairs, disengage PTO, move shift lever into neutral position, set parking brake, stop engine and remove key to prevent unintended starting.
Engine
Refer to the Engine Operator/Owner Manual for engine maintenance instructions.
Check engine oil level before each use as instructed in the Engine Operator/Owner Manual packed with your unit. Follow the instructions carefully.
Changing Engine Oil
NOTE: Depending on the engine model found on your tractor, it may be necessary to remove the tractor’s side panel in order to replace the oil filter (if so equipped).
1.Pop open the protective cap on the end of the oil drain valve to expose the drain port. See Figure
2.Remove the oil fill cap/ dipstick from the oil fill tube.
3.Push the oil drain hose (packed with this manual) onto the oil drain port. Route the opposite end of the hose into an appropriate oil collection container with a capacity great enough to collect the used oil.
4.After the oil has finished draining, push the oil drain valve back in, rotate it clockwise to lock the valve closed and
5.Service the oil filter (if so equipped) as instructed in the separate Engine Operator/Owner Manual packed with your unit.
Perform the above steps in the opposite order after oil has finished draining.
6.Refill the engine with new motor oil as instructed in the Engine Operator/Owner Manual packed with your unit.
Lubrication
WARNING: Before lubricating, repairing, or inspecting, always disengage PTO, move shift lever into neutral position, set parking brake, stop engine and remove key to prevent unintended start- ing.
Engine
Lubricate the engine with motor oil as instructed in the Engine Owner Manual packed with your unit.
Pivot Points & Linkage
Lubricate all the pivot points on the drive system, parking brake, and lift linkage at least once a season with light oil.
Rear Wheels
The rear wheels should be removed from the axles once a season. Lubricate the axles and the rims well with an
Front Axles
Each end of the tractor’s front pivot bar may be equipped with a grease fitting. Lubricate with a grease gun after every 25 hours of tractor operation.
Cleaning the Engine And Deck
Any fuel or oil spilled on the machine should be wiped off promptly. Do NOT allow debris to accumulate around the cooling fins of the engine or on any other part of the machine.
IMPORTANT: The use of a pressure washer to clean your tractor is NOT recommended. It may cause damage to electrical components, spindles, pulleys, bearings or the engine.
22
