Hustler Turf 927558 Fuel system, Engine oil and filter, Hustler approved filter element only

Change hydraulic system filter element after first 50 hours of tractor operation, then replace filter and oil in reservoir every 500 hours thereafter. Fig. 4-2

The system filter is located in front of the hydraulic reservoir. A standard oil filter wrench is used to change filter, threads are right handed. Use a

Hustler approved filter element only.

IMPORTANT: Prefill the filter element with clean oil, before installing, to prevent drawing air into the system pump.

Fuel system

DANGER: Observe usual fuel handling precautions:

Do not smoke while refueling. Extinguish all cigarettes, cigars, pipes and other sources of ignition.

Do not remove fuel cap or fill tank with engine running or while engine is hot. Clean up any fuel spills.

Allow engine to cool before storing machine inside a building.

Keep fuel away from open flame or spark and store machine away from open flame or spark or pilot light such as on a water heater or appliances.

Use extreme care when handling gasoline and other fuels. They are extremely flammable and vapors are explosive. A fire or explosion from fuel can burn you and others and can damage property.

Refuel outdoors. Never refuel or drain the fuel from the machine indoors.

Never attempt to start engine when there is a strong odor of gasoline or diesel fuel fumes present. Locate and correct cause.

Store fuel in an approved container and keep it out of the reach of children. Never buy more than a 30 day supply of fuel.

Always place fuel containers on the ground away from your vehicle before filling.

Do not fill fuel containers inside a vehicle or on a truck or trailer bed with interior carpets or plastic truck bed liners. Always place fuel containers on the ground away from your vehicle before filling.

When practical, remove gas-powered equipment from the truck or trailer and refuel the equipment with its wheels on the ground. If this is not possible, then refuel such equipment on the truck or trailer using a portable container and not a fuel dispenser nozzle. If a gasoline dispenser nozzle must be used, keep the nozzle in contact with the rim of the fuel tank or container opening at all times until fueling is complete. Do not use a nozzle lock-open device.

Read and observe safety precautions elsewhere in this manual.

WARNING: Gasoline or diesel fuel is harmful or fatal if swallowed.

Long-term exposure to vapors can cause serious injury and illness.

Avoid prolonged breathing of vapors.

Keep face away from nozzle and gas tank or fuel container opening.

Keep gas away from eyes and skin.

If fuel is spilled on clothing, change clothing immediately.

WARNING: Fuel System Under Pressure! The EFI fuel system operates under high pressure, and the fuel filter and fuel line used must be approved system components only. Use of substitute parts can result in system failure, gasoline leakage and possible explosion.

Gasoline units

The fuel tanks are located in the tractor’s fenders.

Use regular unleaded gasoline with an octane rating of 87 or higher. IMPORTANT: Never use methanol, gasoline containing methanol, or gasohol containing more than 10% ethanol because the fuel system could be

Right tank

position

		Left tank
		position
Fuel shut-off valve
Closed position shown		Hustler Z/Super Z shown
	Figure 4-3

Fuel shutoff

position

Left tank position

Fuel shut-off valve
Right fuel tank	Hustler Z Shibaura
position shown	Diesel shown

Figure 4-4

damaged. Do not mix oil with gasoline.

A fuel shut-off valve is located on each tractor. The location and operation of the fuel valve will vary depending upon the unit. Close the fuel valve to prevent fuel flow to the engine. The valve’s two other positions will allow fuel to be drawn from either one or the other fuel tank. Fig. 4-3

Diesel units

The fuel tanks are located in the tractor’s fenders. These engines

requires number 2 diesel fuel only.

Hustler Z Shibaura Diesel tractors are equipped with a fuel shutoff valve located to the right rear of the seat. Rotate the valve to the middle position to allow fuel to flow from the right fuel tank to the fuel pump. The right position prevents fuel flow to the fuel pump. The left position allows fuel to flow from the left fuel tank to the fuel pump. Close this valve to prevent fuel flow to the engine when servicing the fuel system or when transporting the unit on a trailer or truck. Fig. 4-4

If the diesel fuel system runs dry, use the following procedure when re- starting the engine:

1.Refill the fuel tanks.

2.Make sure the fuel shutoff valve is turned to the full fuel tank.

3.Take the priming bulb and compress it until it becomes firm. Fig. 4-5

4.Try and start the engine. If it will not start after 15 seconds of cranking, repeat Step 3.

5.If after trying several tries, the engine still will not start, contact your Hustler Dealer.

Engine oil and filter

Check engine oil daily and after every 4 hours of operation. Tractor must be setting level when checking oil. Refer to engine manual and maintenance schedule for oil recommendation and capacities.

Change the engine oil and filter after the first 5 hours of operation (50

601656_1108 27