STORAGE
When storing the unit at the the end of the mowing season, the following steps should be taken to ensure readiness for the next mowing season.
1.Remove all grass, dirt, and trash from tractor and mower. Clean tractor and mower and touch up all scrapes with Hustler spray paint.
2.Replace air filter element.
3.Check thoroughly for any worn or damaged parts that need replacing and order them from your dealer.
4.Thoroughly lubricate machine, according to lubrication instructions.
5.Check hydraulic oil level. Add oil if necessary or change oil and filter if not done in last 500 hours. Refer to Maintenance section.
6.Block tractor up so weight is off tires. NOTE: Do not deflate tires.
7.Perform separate engine and battery preparation as listed below.
8.Store tractor in a clean, dry place.
Preparation of engine for storage
When engine is to be unused for long periods, proceed as follows:
1.Run engine for a minimum of 15 minutes.
2.Drain oil from crankcase while engine is still warm.
3.Refill with fresh oil of proper viscosity.
4.Drain fuel tanks.
5.Remove and replace fuel filter.
6.Clean exterior surface of engine. Spread a light film of oil over any exposed metal surfaces of engine that are subject to corrosion.
7.Check oil filler cap and fuel tank cap to make certain they are securely in place.
Preparation of batteries for storage
When the machine is to be unused for long periods, it is best to disconnect the batteries and remove them from the unit. At this time perform the following battery maintenance:
1.Clean battery
2.Check the electrolyte level
3.Charge the battery, if necessary
4.Store battery in a cool, dry place (do not expose to freezing temperatures)
5.Always keep the battery fully charged. (Especially important to prevent battery damage when the temperature is below 32F.)
New season preparation
Before starting the tractor following post season storage, the following servicing is required:
1.Clean tractor, removing trash and dirt accumulation.
2.Check engine oil, hydraulic oil and coolant levels.
3.Fill fuel tanks with fresh fuel. Bleed fuel system as outlined in Maintenance section. Run machine at half speed for 5 minutes, checking operation of steering control lever. Stop engine and check for oil leaks, loose fittings and so forth.
WARNING: At start of new season always check that fresh oil and coolant have been added to machine. If oil and coolant are drained at season’s end and not replaced, engine damage will result.
4.Tighten any bolts that have loosened and make sure all hair pins, cotter pins and clevis pins are in place.
5.Install all safety shields and review safety precautions listed in this manual.
6.Check and inflate tires to
7.Install fully charged batteries and attach the battery cables.
PRODUCT LITERATURE
This section contains sources of additional literature concerning your tractor. Literature should be ordered from your Hustler dealer or direct from indicated source.
Parts Manuals
If you would like to order a Parts Manual for a particular tractor, the Hustler part number for that manual is listed in the following chart. Please contact your Hustler dealer to order the manual.
|
|
| Parts |
|
|
| Model | Manual | List |
Model |
| Number | P/N | Price |
|
|
|
| |
Hustler Z XR7 | 927723, 927731, 927749, 927756, | 106567 | $22.50 | |
| 927772, 927798, 927806, 927814 |
|
| |
Hustler Z XR7 | 927723 A/B, 927749 A/B, 927756 A/B, | 108602 | $22.50 | |
| 927772 | A/B, 927798 A/B, 927806 A/B, |
|
|
| 927814 | A/B, 928432, 928853 A/B, |
|
|
| 928861 | A/B |
|
|
|
|
|
| |
Super Z XR7 | 927467, 927624, 927673, 927681, | 106575 | $22.50 | |
| 927848, 927855, 927871, 927889, |
|
| |
| 927897, 927913, 927921, 927939, |
|
| |
| 927947, 927970, 927988, 927996, |
|
| |
| 928002, 928010, 928028, 928036, |
|
| |
| 928044, 928051, 928069 |
|
| |
|
|
|
| |
Super Z XR7 | 927467, 927624, 927673, 927681, | 108603 | $22.50 | |
| 927848 | A/B, 927855 A/B, 927871 A/B, |
|
|
| 927889 | A/B, 927897 A/B, 927913 A/B, |
|
|
| 927921 | A/B, 927939 A/B, 927947 A/B, |
|
|
| 927970 | A/B, 927988 A/B, 928010 A/B, |
|
|
| 928028 | A/B, 928036 A/B, 928044 A/B, |
|
|
| 928051 | A/B, 928069 A/B, 928879 A/B, |
|
|
| 928887 | A/B/HTB, 928895 A/B, |
|
|
| 928911 | A/B, 928929, 928937 |
|
|
|
|
|
| |
Hustler Z Diesel | 928606 A/B, 928614 A/B, 928622 A/B, | 109706 | $22.50 | |
Shibaura engine | 928648, 928655 |
|
| |
|
|
|
| |
ATZ XR7 | 928226, 928234 | 107906 | $22.50 | |
|
|
|
|
|
601656_1108 | 41 |