Poulan 96042010900, PB23H48YT, 433413 manual Transmission

Page 24

SERVICE AND ADJUSTMENTS

REPLACING BATTERY (See Fig. 37)

WARNING: Do not short battery termi- nals by allowing a wrench or any other object to contact both terminals at the same time. Before connecting battery, remove metal bracelets, wristwatch bands, rings, etc. Positive terminal must be connected first to prevent sparking from accidental grounding.

Lift hood to raised position.

Remove terminal cover.

Disconnect BLACK battery cable then RED battery cable and carefully remove battery from tractor.

Install new battery with terminals in same position as old battery.

Reinstall terminal cover.

First connect RED battery cable to positive (+) battery terminal with bolt and nut as shown. Tighten securely.

Connect BLACK grounding cable to negative (-) battery terminal with remaining bolt and nut. Tighten securely

Close hood.

NEGATIVE (BLACK)

CABLE

TERMINAL

COVER

POSITIVE (RED)

CABLE

Fig. 37

TO REPLACE HEADLIGHT BULB

Raise hood.

Pull bulb holder out of the hole in the backside of the grill.

Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.

Close hood.

INTERLOCKS AND RELAYS

Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting.

Check wiring.

TO REPLACE FUSE

Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash.

TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 38)

Raise hood.

Unsnap headlight wire connector.

Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.

To replace, reverse above procedure.

HOOD

HEADLIGHT

WIRE

CONNECTOR

02778

Fig. 38

TRANSMISSION

REMOVAL/REPLACEMENT

Should your transmission require removal for service or replacement, it should be purged after reinstallation and beforeoperatingthetractor. See“PURGETRANSMISSION” in the Operation section of this manual.

ENGINE

TO ADJUST THROTTLE CONTROL CABLE

The throttle control has been preset at the factory and adjustment should not be necessary. If adjustment is nec- essary, see engine manual.

TO ADJUST CHOKE CONTROL

The choke control has been preset at the factory and adjust- ment should not be necessary. If adjustment is necessary, see engne manual.

TO ADJUST CARBURETOR

Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.

24

Image 24
Contents PB23H48YT Safety Rules Safe Operation Practices for Ride-On MowersGeneral Operation II. Slope OperationService General ServiceIII. Children IV. TowingTable of Contents Assembly Tools Required for AssemblyUnassembled Parts To Remove Tractor from CartonCheck Tire Pressure Check Deck LevelnessCheck for Proper Position of ALL Belts Check Brake SystemOperation Know Your Tractor HOW to USE Your Tractor To SET Parking Brake See FigStopping See Fig To USE Throttle Control D See FigTo Adjust Mower Cutting Height See Fig To Adjust Gauge Wheels See FigTo Move Forward and Backward See Fig To USE Cruise Control J See FigService REMINDER/HOUR Meter To Operate MowerReverse Operation System ROS To Operate on HillsBefore Starting the Engine Check Engine OIL LevelADD Gasoline To Start Engine See FigMowing Tips Purge TransmissionMaintenance MaintenanceGeneral Recommendations ScheduleBattery TractorBlade Care Blade Removal See FigEngine Cleaning MufflerIN-LINE Fuel Filter See Fig Deck Washout Port See FigService and Adjustments To Install Mower See FigsTo Remove Mower See Fig First Install ANTI-SWAY BAR S M F Visual SIDE-TO-SIDE Adjustment See Fig Precision SIDE-TO-SIDE Adjustment See FigTo Level Mower Turn nut right Turn nut left To raise mowerTo Replace Mower Blade Drive Belt See Fig To Replace Motion Drive Belt See FigTo Adjust Steering Wheel Alignment To Start Engine with a Weak Battery See FigTo Check Brake Front Wheel TOE-IN/CAMBERTransmission Storage OtherFuel System Engine OILTroubleshooting Problem Cause CorrectionTo run when oper Battery will notFires when turn Engine continuesService Notes Suggested Guide for Sighting Slopes for Safe Operation Parts and Service Changere DE Pièces LES ET L’ENTRETIEN Degrés MAX ’ENTRETIEN Remarques Dépannage DE Guide Correction Cause ProblèmePuissance de Entreposage Reglages ET Revision MoteurRossage AVANT/CAR Roues DES ConvergenceLA DE L’ALIGNEMENT Régler Pour Fig la Voir Faible RietebatFig la Voir D’ENTRAÎNEMENT Courroie Acer Rempl PourFig la Voir Tondeuse LA DE Lame Freins LES Vérifier Pour LA DE Courroie LA Remplacer PourTondeuse LA Niveau LE Ajuster Pour 33 .Fig32 .Fig 31 .FigAvant l’embrayage de poulie la sur courroie la Installez 29 .Fig28 .Fig 27 .Fig26 .FIG 25 .FIG24 .FIG 23 .FIGTondeuse LA Installer 29 20 .Figs les Voir18 20 .Fig 21 .Fig Stationnement de frein le actionnez et niveauLigne EN Installé D’ESSENCE Filtre EntretienFig La Voir Coupe DE Plateau DU Lavage DE Raccord Silencieux’ALLUMAGE Bougie Ventilation DE Système’AIR Tamis LE Nettoyer AIR À FiltreFig la Voir Lame LA Enlever Lames DES EntretienPneus Frein DU FonctionnementUtilisation Chaque Avant Lubrification DE TableauAvant ET Réinstallation LA Après Purgée Être UtilisationTransmission LA Purger 13 .Fig’ESSENCE Réservoir LE Remplir Moteur DU D’HUILE Niveau LE VérifierAccessoires Autres ET Charrettes DES Remorquer Pour ROS Arrière Marche EN Fonctionnement DE SystèmeTracteur LE Transporter Pour Pentes LES Dans Utiliser PourTondeuse DE Lames LES Arrêter Pour Jauge DE Roues LES Régler PourFig la Voir J Vitesse DE Régulateur LE Utiliser Comment Tondeuse LA Utiliser PourGAZ DES Commande LA Utiliser Pour Fig la Voir Arrêter PourFig la Voir Mentnetionsta DE Frein LE Embrayée Pour Entraînement’ACCESSOIRE D’EMBRAYAGE Interrupteur E Frein DE Pédale Montage Montées NON Piéces Desmancom des fonction la etTionsec la Voir Rouler Faisant LE EN TE Fig la SIÈGEVoir LE Régler PourUtilisation MontageClient DU Responsabilités Produit DE SpécificationsSécurité DE Règles Tracteurs des sécurité touteEnfants En l’utilisation pour ConseilsAvertissement Tracteurs des sécurité toute en l’utilisation pour ConseilsPentes LES Dans Fonctionnement Général FonctionnementCom.pro-poulan.www web site notre Visitez Avertissement