Poulan PB175H42LT manual Engine dies when

Page 26

TROUBLESHOOTING POINTS

PROBLEM

CAUSE

CORRECTION

 

 

 

 

 

Engine dies when

1.

Reverse operation system

1.

Turn ignition key to

tractor is shifted

 

(ROS) is not "ON" while

 

ROS "ON" position.

into reverse

 

mower or other attachment

 

See Operation section.

 

 

is engaged.

 

 

 

 

 

 

 

Engine continues to run

1.

Faulty operator-safety presence control system.

1.

Check wiring, switches and connections. If not

when operator leaves seat

 

 

 

corrected, contact an authorized service center/

with attachment clutch

 

 

 

department.

engaged

 

 

 

 

 

 

 

 

 

Poor cut - uneven

1.

Worn, bent or loose blade.

1.

Replace blade. Tighten blade bolt.

 

2.

Mower deck not level.

2.

Level mower deck.

 

3.

Buildup of grass, leaves, and trash under mower.

3.

Clean underside of mower housing.

 

4.

Bent blade mandrel.

4.

Replace blade mandrel.

 

5.

Clogged mower deck vent holes from buildup of

5.

Clean around mandrels to open vent holes.

 

 

grass, leaves, and trash around mandrels.

 

 

 

 

 

 

 

Mower blades will not

1.

Obstruction in clutch mechanism.

1.

Remove obstruction.

rotate

2.

Worn/damaged mower drive belt.

2.

Replace mower drive belt.

 

3.

Frozen idler pulley.

3.

Replace idler pulley.

 

4.

Frozen blade mandrel.

4.

Replace blade mandrel.

 

 

 

 

 

Poor grass discharge

1.

Engine speed too slow.

1.

Place throttle control in “FAST” position.

 

2.

Travel speed too fast.

2.

Shift to slower speed.

 

3.

Wet grass.

3.

Allow grass to dry before mowing.

 

4.

Mower deck not level.

4.

Level mower deck.

 

5.

Low/uneven tire air pressure.

5.

Check tires for proper air pressure.

 

6.

Worn, bent or loose blade.

6.

Replace/sharpen blade. Tighten blade bolt.

 

7.

Buildup of grass, leaves and trash under mower.

7.

Clean underside of mower housing.

 

8.

Mower drive belt worn.

8.

Replace mower drive belt.

 

9.

Blades improperly installed.

9.

Reinstall blades sharp edge down.

 

10.

Improper blades used.

10.

Replace with blades listed in this manual.

 

11.

Clogged mower deck vent holes from buildup of

11.

Clean around mandrels to open vent holes.

 

 

grass, leaves, and trash around mandrels.

 

 

 

 

 

 

 

Headlight(s) not working

1.

Light switch is “OFF”.

1.

Turn light switch “ON”.

(if so equipped)

2.

Bulb(s) or lamp(s) burned out.

2.

Replace bulb(s) or lamp(s).

 

3.

Faulty light switch.

3.

Check/replace light switch.

 

4.

Loose or damaged wiring.

4.

Check wiring and connections.

 

5.

Blown fuse.

5.

Replace fuse.

 

 

 

 

 

Battery will not charge

1.

Bad battery cell(s).

1.

Replace battery.

 

2.

Poor cable connections.

2.

Check/clean all connections.

 

3.

Faulty regulator (if so equipped).

3.

Replace regulator.

 

4.

Faulty alternator.

4.

Replace alternator.

 

 

 

 

 

Loss of drive

1.

Freewheel control in “disengaged” position.

1.

Place freewheel control in “engaged” position.

 

2.

Motion drive belt worn, damaged, or broken.

2.

Replace motion drive belt.

 

3.

Air trapped in transmission during shipment

3.

Purge transmission.

 

 

or servicing.

 

 

 

 

 

 

 

Engine “backfires” when

1.

Engine throttle control not set between half and

1.

Move throttle control between half and full speed

turning engine “OFF”

 

full speed (fast) position before stopping engine.

 

(fast) position before stopping engine.

 

 

 

 

 

26

Page 25 Page 27
Image 26
Page 25 Page 27
Contents Model PB18H42LTGeneral Operation Safety RulesSafe Operation Practices for Ride-On Mowers II. Slope OperationIII. Children ServiceGeneral Service IV. TowingTable of Contents Slope Sheet Unassembled PartsSteering Wheel Seat To Remove Tractor from Carton AssemblyTools Required for Assembly Before Removing Tractor from SkidCheck Battery See Fig Check for Proper Position of ALL Belts Check Tire PressureCheck Deck Levelness Check Brake SystemOperation Know Your Tractor HOW to USE Your Tractor Reverse Operation System ROS Using the Reverse Operation SystemTo Operate Mower See Fig To Operate on HillsCheck Engine OIL Level Before Starting the EngineTo Transport See Figs ADD GasolineAutomatic Transmission Warm UP Mowing TipsPurge Transmission NingMaintenance Lubrication ChartTo Sharpen Blade See Fig TractorBlade Removal See Fig Engine AIR Filter CleaningClean AIR Screen MufflerTo Level Mower Housing Service and AdjustmentsTo Install Mower See Fig To Remove Mower See FigBelt Removal Belt InstallationTo Replace Mower Blade Drive Belt See Fig To Adjust Brake To Check and Adjust Brake See FigTransaxle Motion Control Lever Neutral Adjustment See Fig To Replace Motion Drive Belt See FigTo Start Engine with a Weak Battery See Fig Transmission REMOVAL/REPLACEMENTTo Adjust Steering Wheel ALIGN- Ment Front Wheel TOE-IN/CAMBERTo Adjust Carburetor To Adjust Throttle Control CableTo Adjust Choke Control To Replace Headlight BulbFuel System StorageOther Engine OILTroubleshooting Points Problem Cause CorrectionEngine dies when Limited Warranty L5V 3E4Service Notes Suggested Guide for Sighting Slopes for Safe Operation Parts and Service Changere DE Pièces LES ET L’ENTRETIEN Degrés Dentretien Notes Autorisé Garantie cette de exclus sont normal l’entretien etDépannage DE Guide Correction Cause ProblèmeLame de mandrin le Remplacez Tordu est lame de mandrin Un Tracteur EntreposageMoteur 27 et 26 .Fig les Voir Reglages ET RevisionCarburateur LE Régler Pour Batterie LA ReplacerAVANT/CAR Roues DES Convergence LA DE ENLEVEMENT/REMPLACEMENTRossage LA DE L’ALIGNEMENT Régler PourFrein LE Régler ET Contrôler Pour Fig la Voir’EN Courroie LA Remplacer Pour Transmission DE MentnetraîCourroie Acer Rempl Pour Tondeuse DE Lame DE MENTNETRAÎD’ENLautre À Côté DUN Réglage Tondeuse DE Boîtier LE Niveler Pour15 .FIG Entretien MoteurFig la Voir Lame LA Affiler Sionmistrans LA DE Moteur FluideTransmission LA DE Refroidissement Trapézoïdales CourroiesFig la Voir Lame LA Enlever EN Fonctionnement DE Système ETLubrification DE Tableau Recommandations LESGénérales Utilisation Chaque AvantTransmission LA Purger UtilisationTondre DE Conseils QuetiMoteur LE Démarrer DE Avant Tracteur LE Transporter Pour Et 4 .Fig les VoirEN Fonctionnement DE Système Pentes LES Dans Utiliser PourFig la Voir Arrêter Pour GAZ DES Commande LA Utiliser PourTeurtrac Votre Utiliser Comment Fig la Voir Mentnetionsta DE Frein LE Engager PourLSW02838 ’EMBRAYAGE Montage NI DE EST Tondeuse LA SI VérifierPA LA DE Tracteur LE Retirer Pour Palette LA Fig la Voir Siège LE InstallerDU Tracteur LE Sortir Pour ToncarClés Montées NON PiécesPente-Guide Siège Direction de VolantProduit DE Spécifications SommaireClient DU Responsabilités Enfants EntretienRemorquage Général EntretienGénéral Fonctionnement TESPEN LES Dans Fonctionnement Tracteurs des sécurité toute en l’utilisation pour ConseilsAvertissement ModèleAUX Imprimé

PB175H42LT specifications

The Poulan PB175H42LT is a robust lawn tractor designed for homeowners seeking an efficient and reliable solution for lawn maintenance. With a focus on power, comfort, and versatility, this model stands out as a great option for handling a variety of mowing tasks.

One of the key features of the PB175H42LT is its powerful 17.5 HP Briggs & Stratton engine. This engine offers reliable starting and performance, making it suitable for tackling both small and large yards. The automatic hydrostatic transmission enhances the driving experience by providing a smooth and effortless change of speed without the need for shifting gears. This means users can focus more on mowing rather than managing complicated controls.

The 42-inch cutting deck of the Poulan PB175H42LT is designed for efficiency and precision. With its three-blade system, it delivers an even and clean cut, reducing the number of passes needed to achieve a well-manicured lawn. The deck is also adjustable, allowing users to set their desired cutting height between 1.5 to 4 inches, catering to various grass types and preferences.

Comfort is a priority with the PB175H42LT, which features a comfortable high back seat and easy-to-reach controls. The tractor's design also includes a tight turning radius, making it easy to navigate around flower beds and trees. Additionally, the generous legroom and ergonomic layout ensure that users can operate the tractor for extended periods without discomfort.

The Poulan PB175H42LT incorporates several technologies that enhance its functionality. For example, the Easy Start technology allows for quick engine ignition, so users can get started with their mowing tasks without delay. The integrated mulching capability provides added versatility, enabling homeowners to fertilize their lawns naturally while maintaining a tidy appearance.

Durability is another hallmark of the Poulan brand, and the PB175H42LT is built to last. Its heavy-duty construction ensures that the tractor can withstand regular use and varying conditions, making it a solid investment for any homeowner.

In summary, the Poulan PB175H42LT is a well-designed lawn tractor that combines power, comfort, and advanced features. Its reliable engine, adjustable cutting deck, and user-friendly controls make it an excellent choice for maintaining a beautiful lawn with ease. Whether tackling tough weeds or managing routine mowing, this model delivers the performance and reliability homeowners need.
Top Page Image Contents