Poulan PO12538LT manual To Replace Headlight Bulb, Interlocks and Relays, To Replace Fuse

Page 23

SERVICE AND ADJUSTMENTS

REPLACING BATTERY (See Figs. 24 and 25)

WARNING: Do not short battery terminals by allowing a wrench or any other object to contact both terminals at the same time. Before connect- ing battery, remove metal bracelets, wristwatch bands, rings, etc.

Positive terminal must be connected first to prevent sparking from acci- dental grounding.

•Lift seat pan to raised position.

•Disconnect BLACK battery cable first then RED battery cable and carefully remove battery from tractor.

•Install new battery with terminals in same position as old battery.

•First connect RED battery cable to positive (+) terminal with hex bolt and keps nut as shown. Tighten securely. Slide terminal cover over terminal.

•Connect BLACK grounding cable to negative (-) ter- minal with remaining hex bolt and keps nut. Tighten securely.

SEAT PAN

FIG. 24

TERMINAL

KEPS NUT

COVER

 

HEX

BOLT

POSITIVE (RED) CABLE

NEGATIVE (BLACK) CABLE

FIG. 25

TO REPLACE HEADLIGHT BULB

•Raise hood.

•Pull bulb holder out of the hole in the backside of the grill.

•Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.

•Close hood.

INTERLOCKS AND RELAYS

Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting.

•Check wiring. See electrical wiring diagram in the Repair Parts section.

TO REPLACE FUSE

Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash.

TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 26)

•Raise hood.

•Unsnap headlight wire connector.

•Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.

•To replace, reverse above procedure.

HOOD

HEADLIGHT WIRE

CONNECTOR

01536

FIG. 26

ENGINE

TO ADJUST THROTTLE CONTROL CABLE

The throttle control has been preset at the factory and adjustment should not be necessary. If adjustment is nec- essary, see engine manual.

TO ADJUST CHOKE CONTROL

The choke control has been preset at the factory and ad- justment should not be necessary. If adjustment is neces- sary, see engne manual.

TO ADJUST CARBURETOR

Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.

23

Page 22 Page 24
Image 23
Page 22 Page 24
Contents Always Wear EYE Protection During Operation ModelII. Slope Operation Safety RulesSafe Operation Practices for Ride-On Mowers General OperationIV. Towing ServiceGeneral Service III. ChildrenTable of Contents Contents of Hardware Pack Before Removing Tractor from Skid AssemblyTools Required for Assembly To Remove Tractor from CartonCheck Battery See Fig Check Brake System Check Tire PressureCheck Deck Levelness Check for Proper Position of ALL BeltsOperation Know Your Tractor HOW to USE Your Tractor To Transport Reverse Operation System ROSTo Operate Mower See Fig To Operate on HillsTo Start Engine See Fig Before Starting the EngineCheck Engine OIL Level ADD GasolineMowing Tips General Recommendations MaintenanceTo Sharpen Blade See Fig TractorBlade Removal See Fig Transaxle Cooling BatteryEngine BeltsMuffler CleaningClean AIR Screen AIR FilterTo Remove Mower See Fig Service and AdjustmentsTo Install Mower See Fig Belt Removal To Level Mower HousingBelt Installation To Replace Mower Blade Drive Belt See FigTo Check Brake To Check and Adjust Brake See FigTo Adjust Brake To Replace Motion Drive Belt See FigFront Wheel TOE-IN/CAMBER Transaxle Gear Shift Lever NEUTRAL- Adjustment See FigTo Adjust Steering Wheel ALIGN- Ment To Start Engine with a Weak Battery See FigTo Replace Headlight Bulb To Adjust Throttle Control CableTo Adjust Choke Control To Adjust CarburetorEngine OIL StorageOther Fuel SystemProblem Cause Correction Troubleshooting PointsEngine dies when Limited Warranty Service Notes Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationParts and Service
Related manuals
Manual 28 pages 56.25 Kb

PO12538LT specifications

The Poulan PO12538LT is a remarkable lawn tractor designed for homeowners seeking efficiency and reliability in maintaining their lawns. This powerful machine combines robust construction with user-friendly features that make grass cutting a breeze.

At the heart of the Poulan PO12538LT is a robust 12 HP Briggs & Stratton engine. This engine provides ample power for tackling various terrains, whether they are flat or hilly. The engine's design emphasizes longevity and ease of starting, ensuring that users can begin their lawn maintenance tasks without hassle.

One of the standout features of the PO12538LT is its 38-inch cutting deck. This size allows for efficient maneuvering in tight spaces while still providing wide cutting coverage. The cutting deck is equipped with three adjustable blades, which can easily be set to different cutting heights. This feature is essential for achieving the desired grass length, making it ideal for users who prefer a well-manicured lawn.

The tractor utilizes a foot pedal-operated transmission that enables seamless speed adjustments. Operators can effortlessly move forward or reverse without having to disengage from the cutting deck, enhancing the overall mowing experience. This allows for greater control and precision, especially around obstacles like flower beds or trees.

Comfort is a significant focus in the design of the PO12538LT. The seat is designed to provide ample support during extended mowing sessions, reducing fatigue for the operator. Additionally, the tractor incorporates a compact, ergonomic layout that ensures easy access to controls and features, promoting a user-friendly experience.

Another innovative characteristic of the Poulan PO12538LT is its maintenance-friendly design. The easy-clean cutting deck facilitates quick cleaning after mowing, and the accessible engine compartment allows for straightforward maintenance, ensuring the tractor runs efficiently for years.

Moreover, the PO12538LT features an integrated grass catcher option, enabling homeowners to collect clippings for a tidy lawn appearance. This optional accessory can be attached and detached with ease, contributing to the convenience of the tractor.

In summary, the Poulan PO12538LT lawn tractor is an excellent choice for homeowners looking to maintain their yards efficiently. With its powerful engine, adjustable cutting deck, user-friendly controls, and comfort-focused design, it proves to be both reliable and versatile. Whether you have a small suburban yard or a slightly larger plot, the PO12538LT stands ready to tackle your lawn maintenance needs with performance and ease.
Top Page Image Contents