Poulan PPH23B48 manual Transmission

Page 24

SERVICE AND ADJUSTMENTS

REPLACING BATTERY (See Fig. 37)

WARNING: Do not short battery termi- nals by allowing a wrench or any other object to contact both terminals at the same time. Before connecting battery, remove metal bracelets, wristwatch bands, rings, etc. Positive terminal must be connected first to prevent sparking from accidental grounding.

•Lift hood to raised position.

•Remove terminal cover.

•Disconnect BLACK battery cable then RED battery cable and carefully remove battery from tractor.

•Install new battery with terminals in same position as old battery.

•Reinstall terminal cover.

•First connect RED battery cable to positive (+) battery terminal with bolt and nut as shown. Tighten securely.

•Connect BLACK grounding cable to negative (-) battery terminal with remaining bolt and nut. Tighten securely

•Close hood.

NEGATIVE (BLACK)

CABLE

TERMINAL

COVER

POSITIVE (RED)

CABLE

Fig. 37

TO REPLACE HEADLIGHT BULB

•Raise hood.

•Pull bulb holder out of the hole in the backside of the grill.

•Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill.

•Close hood.

INTERLOCKS AND RELAYS

Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting.

•Check wiring.

TO REPLACE FUSE

Replace with 20 amp automotive-type plug-in fuse. The fuse holder is located behind the dash.

TO REMOVE HOOD AND GRILL ASSEMBLY (See Fig. 38)

•Raise hood.

•Unsnap headlight wire connector.

•Stand in front of tractor. Grasp hood at sides, tilt toward engine and lift off of tractor.

•To replace, reverse above procedure.

HOOD

HEADLIGHT

WIRE

CONNECTOR

03075

Fig. 38

TRANSMISSION

REMOVAL/REPLACEMENT

Should your transmission require removal for service or replacement, it should be purged after reinstallation and beforeoperatingthetractor. See“PURGETRANSMISSION” in the Operation section of this manual.

ENGINE

TO ADJUST THROTTLE CONTROL CABLE

The throttle control has been preset at the factory and adjustment should not be necessary. If adjustment is nec- essary, see engine manual.

TO ADJUST CHOKE CONTROL

The choke control has been preset at the factory and adjust- ment should not be necessary. If adjustment is necessary, see engne manual.

TO ADJUST CARBURETOR

Your carburetor is not adjustable. If your engine does not operate properly due to suspected carburetor problems, take your tractor to an authorized service center for repair and/or adjustment.

24

Page 23 Page 25
Image 24
Page 23 Page 25
Contents PPH23B48 Safety Rules Safe Operation Practices for Ride-On MowersGeneral Operation II. Slope OperationService General ServiceIII. Children IV. TowingTable of Contents Assembly Tools Required for AssemblyUnassembled Parts To Remove Tractor from CartonCheck Tire Pressure Check Deck LevelnessCheck for Proper Position of ALL Belts Check Brake SystemOperation Know Your Tractor HOW to USE Your Tractor Attachment Clutch Switch Disengaged EngagedTo SET Parking Brake See Fig Stopping See FigTo Adjust Mower Cutting Height See Fig To Adjust Gauge Wheels See FigTo Move Forward and Backward See Fig To USE Cruise Control J See FigService REMINDER/HOUR Meter To Operate MowerReverse Operation System ROS To Operate on HillsBefore Starting the Engine Check Engine OIL LevelADD Gasoline To Start Engine See FigMowing Tips Purge TransmissionMaintenance Lubrication ChartPowdered Graphite Type Lubricant Sparingly Battery TractorBlade Care Blade Removal See FigEngine Cleaning Service and Adjustments To Install Mower See FigsTo Remove Mower See Fig First Install ANTI-SWAY BAR S M F Engage belt tension rod K on locking bracket LVisual SIDE-TO-SIDE Adjustment See Fig Precision SIDE-TO-SIDE Adjustment See FigTo Level Mower Turn nut right Turn nut left To raise mowerTo Replace Mower Blade Drive Belt See Fig To Check BrakeTo Replace Motion Drive Belt See Fig To Adjust Steering Wheel Alignment To Start Engine with a Weak Battery See FigFront Wheel TOE-IN/CAMBER To Remove Wheel for Repairs See FigTransmission Storage OtherFuel System Engine OILTroubleshooting Problem Cause CorrectionTo run when oper Battery will notFires when turn Engine continuesService Notes Suggested Guide for Sighting Slopes for Safe Operation Parts and Service Changere DE Pièces LES ET L’ENTRETIEN Degrés MAX ’ENTRETIEN Remarques Dépannage DE Guide Correction Cause ProblèmePuissance de Entreposage Starter DU Commande LA Régler Pour Reglages ET RevisionMoteur Carburateur LE Régler PourRossage AVANT/CAR Roues DES ConvergenceLA DE L’ALIGNEMENT Régler Pour Fig la Voir Faible RietebatFig la Voir D’ENTRAÎNEMENT Courroie Acer Rempl PourFig la Voir Tondeuse LA DE Lame Freins LES Vérifier Pour LA DE Courroie LA Remplacer PourTondeuse LA Niveau LE Ajuster Pour 32 .Fig31 .Fig 30 .FigAvant l’embrayage de poulie la sur courroie la Installez 28 .Fig27 .Fig 26 .Fig25 .FIG 24 .FIG23 .FIG 22 .FIGTondeuse LA Installer 28 19 .Figs les Voir18 19 .Fig 20 .Fig Stationnement de frein le actionnez et niveauEntretien Sionmistrans LA DE Moteur Fluide Fig La Voir Coupe DE Plateau DU Lavage DE RaccordLubrification Transmission LA DE EntretienFig la Voir Lame LA Enlever Lames DES EntretienPneus Frein DU FonctionnementUtilisation Chaque Avant Lubrification DE TableauAvant ET Réinstallation LA Après Purgée Être UtilisationTransmission LA Purger 13 .Fig’ESSENCE Réservoir LE Remplir Moteur DU D’HUILE Niveau LE VérifierAccessoires Autres ET Charrettes DES Remorquer Pour ROS Arrière Marche EN Fonctionnement DE SystèmeTracteur LE Transporter Pour Pentes LES Dans Utiliser PourTondeuse DE Lames LES Arrêter Pour Jauge DE Roues LES Régler PourFig la Voir J Vitesse DE Régulateur LE Utiliser Comment Tondeuse LA Utiliser PourGAZ DES Commande LA Utiliser Pour Fig la Voir Arrêter PourFig la Voir Mentnetionsta DE Frein LE Embrayée Pour Moteur’ACCESSOIRE D’EMBRAYAGE Interrupteur E Propriété la de lendommagement et/ou sérieuses Montage NI DE EST Tondeuse LA SI VérifierMontées NON Piéces DU Tracteur LE Sortir PourUtilisation MontageClient DU Responsabilités Produit DE SpécificationsEnfants EntretienRemorquage Général EntretienAvertissement Pentes LES Dans FonctionnementTracteurs des sécurité toute en l’utilisation pour Conseils Général FonctionnementU the in Printed SR 09.06.02 Avertissement

PPH23B48 specifications

The Poulan PPH23B48 is a versatile and powerful lawn tractor designed for homeowners who demand efficiency and comfort in their outdoor mowing tasks. Engineered to handle a variety of yard sizes, this model boasts a reliable Briggs & Stratton engine that delivers robust performance for tackling grass and terrain with ease.

One of the standout features of the PPH23B48 is its 48-inch cutting deck. This wide cutting path allows for quicker mowing sessions, enabling users to cover more ground in less time. The deck is crafted from durable materials to withstand the rigors of frequent use while providing clean and even cuts. The adjustable cutting height feature offers six positions, allowing operators to customize grass length to suit their preferences and environmental conditions.

The Poulan PPH23B48 is equipped with an innovative hydrostatic transmission system, which contributes to a smoother driving experience. This technology eliminates the need for manual shifting, allowing riders to easily control their speed without the hassle of changing gears. This feature is especially beneficial for navigating various terrains, as it enables seamless transitions from flat lawns to inclines.

Comfort is paramount in the design of the PPH23B48. The ergonomic seat is designed for prolong use, reducing fatigue during longer mowing sessions. With a user-friendly dashboard, operators can quickly monitor fuel levels, engine performance, and operational settings, ensuring efficient management of mowing tasks.

Furthermore, Poulan has incorporated a tight turning radius into this model, which enhances maneuverability around obstacles like trees and flower beds. The easy-to-use steering wheel provides precision control, making it simple for users to navigate their yards effortlessly.

The PPH23B48 is also equipped with a mulching capability, which allows users to recycle grass clippings back into the lawn. This eco-friendly feature not only reduces waste but also adds valuable nutrients back into the soil, promoting a healthier lawn.

In summary, the Poulan PPH23B48 combines power, efficiency, and user-centric design to create a lawn tractor that meets the needs of various homeowners. Its thoughtful features and advanced technologies make outdoor mowing not just a chore, but a manageable and enjoyable task.
Top Page Image Contents