Poulan PPH23B48 Unassembled Parts, Tools Required for Assembly, To Remove Tractor from Carton

Page 5

UNASSEMBLED PARTS

Slope Sheet

Key

(1) Oil Drain Tube

(2) Keys

ASSEMBLY

Your new tractor has been assembled at the factory with the exception of those parts left unassembled for shipping purposes.

TOOLS REQUIRED FOR ASSEMBLY

A socket wrench set will make assembly easier. Standard wrench sizes are listed.

(1)

1/2" wrench

Tire pressure gauge

(2)

7/16" wrenches

Utility knife

 

 

Pliers

When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel).

TO REMOVE TRACTOR FROM CARTON

TO CHECK BATTERY (See Fig. 2)

•Lift hood to raised position.

NOTE: If this battery is put into service after month and year indicated on label (label is located between terminals) charge battery for minimum of one hour at 6-10 amps. (See "BATTERY" in Maintenance section of this manual for charging instructions).

•For battery and battery cable installation see "RE- PLACING BATTERY" in the "Service and Adjustments" section in this manual.

UNPACK CARTON

•Remove all accessible loose parts and parts cartons from carton .

•Cut along dotted lines on all four panels of carton. Remove end panels and lay side panels flat.

•Check for any additional loose parts or cartons and remove.

LABEL

BEFORE REMOVING TRACTOR FROM SKID

TO ADJUST SEAT (See Fig. 1):

•Grasp adjustment handle(A) and pull up, slide seat to desired position and release adjustment handle.

A

Fig. 1

Fig. 2

NOTE: You may now roll your tractor off the skid. Follow the instructions below to remove the tractor from the skid.

WARNING: Before starting, read, understand and follow all instructions in the Operation section of this manual. Be sure tractor is in a well-ventilated area. Be sure the area in front of tractor is clear of other people and objects.

TO ROLL TRACTOR OFF SKID (See Operation section for location and function of controls)

•Raise attachment lift lever to its highest position.

•Releaseparkingbrakebydepressingclutch/brakepedal.

•Place freewheel control in "transmission disengaged" position (See “TO TRANSPORT” in the Operation section of this manual).

•Roll tractor forward off skid.

•Remove banding holding the deflector shield up against tractor.

Continue with the instructions that follow.

5

Page 4 Page 6
Image 5
Page 4 Page 6
Contents PPH23B48 Safe Operation Practices for Ride-On Mowers Safety RulesGeneral Operation II. Slope OperationGeneral Service ServiceIII. Children IV. TowingTable of Contents Tools Required for Assembly AssemblyUnassembled Parts To Remove Tractor from CartonCheck Deck Levelness Check Tire PressureCheck for Proper Position of ALL Belts Check Brake SystemOperation Know Your Tractor Attachment Clutch Switch Disengaged Engaged HOW to USE Your TractorTo SET Parking Brake See Fig Stopping See FigTo Adjust Gauge Wheels See Fig To Adjust Mower Cutting Height See FigTo Move Forward and Backward See Fig To USE Cruise Control J See FigTo Operate Mower Service REMINDER/HOUR MeterReverse Operation System ROS To Operate on HillsCheck Engine OIL Level Before Starting the EngineADD Gasoline To Start Engine See FigPurge Transmission Mowing TipsPowdered Graphite Type Lubricant Sparingly MaintenanceLubrication Chart Tractor BatteryBlade Care Blade Removal See FigEngine Cleaning To Remove Mower See Fig Service and AdjustmentsTo Install Mower See Figs First Install ANTI-SWAY BAR S Engage belt tension rod K on locking bracket L M FPrecision SIDE-TO-SIDE Adjustment See Fig Visual SIDE-TO-SIDE Adjustment See FigTo Level Mower Turn nut right Turn nut left To raise mowerTo Replace Motion Drive Belt See Fig To Replace Mower Blade Drive Belt See FigTo Check Brake To Start Engine with a Weak Battery See Fig To Adjust Steering Wheel AlignmentFront Wheel TOE-IN/CAMBER To Remove Wheel for Repairs See FigTransmission Other StorageFuel System Engine OILProblem Cause Correction TroubleshootingBattery will not To run when operFires when turn Engine continuesService Notes Suggested Guide for Sighting Slopes for Safe Operation Parts and Service Changere DE Pièces LES ET L’ENTRETIEN Degrés MAX ’ENTRETIEN Remarques Correction Cause Problème Dépannage DE GuidePuissance de Entreposage Reglages ET Revision Starter DU Commande LA Régler PourMoteur Carburateur LE Régler PourAVANT/CAR Roues DES Convergence RossageLA DE L’ALIGNEMENT Régler Pour Fig la Voir Faible RietebatCourroie Acer Rempl Pour Fig la Voir D’ENTRAÎNEMENTFig la Voir Tondeuse LA DE Lame Freins LES Vérifier Pour LA DE Courroie LA Remplacer Pour32 .Fig Tondeuse LA Niveau LE Ajuster Pour31 .Fig 30 .Fig28 .Fig Avant l’embrayage de poulie la sur courroie la Installez27 .Fig 26 .Fig24 .FIG 25 .FIG23 .FIG 22 .FIG28 19 .Figs les Voir Tondeuse LA Installer18 19 .Fig 20 .Fig Stationnement de frein le actionnez et niveauEntretien Fig La Voir Coupe DE Plateau DU Lavage DE Raccord Sionmistrans LA DE Moteur FluideLubrification Transmission LA DE EntretienLames DES Entretien Fig la Voir Lame LA EnleverPneus Frein DU FonctionnementLubrification DE Tableau Utilisation Chaque AvantUtilisation Avant ET Réinstallation LA Après Purgée ÊtreTransmission LA Purger 13 .FigMoteur DU D’HUILE Niveau LE Vérifier ’ESSENCE Réservoir LE RemplirROS Arrière Marche EN Fonctionnement DE Système Accessoires Autres ET Charrettes DES Remorquer PourTracteur LE Transporter Pour Pentes LES Dans Utiliser PourJauge DE Roues LES Régler Pour Tondeuse DE Lames LES Arrêter PourFig la Voir J Vitesse DE Régulateur LE Utiliser Comment Tondeuse LA Utiliser PourFig la Voir Arrêter Pour GAZ DES Commande LA Utiliser PourFig la Voir Mentnetionsta DE Frein LE Embrayée Pour Moteur’ACCESSOIRE D’EMBRAYAGE Interrupteur E Propriété la de lendommagement et/ou sérieuses NI DE EST Tondeuse LA SI Vérifier MontageDU Tracteur LE Sortir Pour Montées NON PiécesMontage UtilisationClient DU Responsabilités Produit DE SpécificationsEntretien EnfantsRemorquage Général EntretienPentes LES Dans Fonctionnement AvertissementTracteurs des sécurité toute en l’utilisation pour Conseils Général FonctionnementAvertissement U the in Printed SR 09.06.02

PPH23B48 specifications

The Poulan PPH23B48 is a versatile and powerful lawn tractor designed for homeowners who demand efficiency and comfort in their outdoor mowing tasks. Engineered to handle a variety of yard sizes, this model boasts a reliable Briggs & Stratton engine that delivers robust performance for tackling grass and terrain with ease.

One of the standout features of the PPH23B48 is its 48-inch cutting deck. This wide cutting path allows for quicker mowing sessions, enabling users to cover more ground in less time. The deck is crafted from durable materials to withstand the rigors of frequent use while providing clean and even cuts. The adjustable cutting height feature offers six positions, allowing operators to customize grass length to suit their preferences and environmental conditions.

The Poulan PPH23B48 is equipped with an innovative hydrostatic transmission system, which contributes to a smoother driving experience. This technology eliminates the need for manual shifting, allowing riders to easily control their speed without the hassle of changing gears. This feature is especially beneficial for navigating various terrains, as it enables seamless transitions from flat lawns to inclines.

Comfort is paramount in the design of the PPH23B48. The ergonomic seat is designed for prolong use, reducing fatigue during longer mowing sessions. With a user-friendly dashboard, operators can quickly monitor fuel levels, engine performance, and operational settings, ensuring efficient management of mowing tasks.

Furthermore, Poulan has incorporated a tight turning radius into this model, which enhances maneuverability around obstacles like trees and flower beds. The easy-to-use steering wheel provides precision control, making it simple for users to navigate their yards effortlessly.

The PPH23B48 is also equipped with a mulching capability, which allows users to recycle grass clippings back into the lawn. This eco-friendly feature not only reduces waste but also adds valuable nutrients back into the soil, promoting a healthier lawn.

In summary, the Poulan PPH23B48 combines power, efficiency, and user-centric design to create a lawn tractor that meets the needs of various homeowners. Its thoughtful features and advanced technologies make outdoor mowing not just a chore, but a manageable and enjoyable task.
Top Page Image Contents