Poulan manual Tractor Model Number POGT20H48STA, Product no 56, Schematic

Page 29

TRACTOR - MODEL NUMBER POGT20H48STA, PRODUCT NO. 954 56 94-55

SCHEMATIC

RED

BLACK

BATTERY

								SOLENOID
A		RED					RED	RED	M
A									M
AMMETER			FUSE						STARTER
AMMETER									STARTER
(OPTIONAL)		WHITE		WHITE			WHITE		BLACK
		WHITE		WHITE
RED					C		G
					C		G
B	S	BLACK						ELECTRIC CLUTCH
B	M		CLUTCH / BRAKE		BLACK			ELECTRIC CLUTCH
			CLUTCH / BRAKE				RED
G	A1		(PEDAL UP)			F

							H
L	A2						H
L	A2				B
			RED		B
			RED

BLACK

IGNITION

SWITCH

ORANGE

		E
		A
SEAT SWITCH		D
(NOT OCCUPIED)		D
		PTO (DISENGAGED)
GREEN	GREEN
	BLUE	HOUR	BLACK
		METER

	BLACK
85	86
	BLACK
87	30
	87A
OPERATOR
PRESENCE
RELAY #1

FUEL (OPTIONAL)

LINE

BLACK

BLUE

FUEL SHUT-OFF SOLENOID

RED


				SPARK
IGNITION				SPARK
IGNITION				PLUGS GAP
UNIT				(2 PLUGS ON
			TWIN CYL. ENGINES)
			TWIN CYL. ENGINES)
CHARGING SYSTEM OUTPUT				28 VOLTS AC @ 3600 RPM
16 AMP DC @ 3600 RPM				(REGULATOR DISCONNECTED)

REGULATOR

ALTERNATOR

BROWN

BLACK

IGNITION SWITCH

POSITION	CIRCUIT	“MAKE”


OFF	M+G+A1	NONE
RUN/LIGHT	B+A1	A2+L
RUN	B+A1	NONE
START	B + S + A1	NONE

WIRING INSULATED CLIPS

NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.

PTO SWITCH

POSITION	CIRCUIT


OFF	C + G, B + H
ON	C + F, B + E, A + D

NON-REMOVABLE REMOVABLE

CONNECTIONS CONNECTIONS

					HEADLIGHTS



		87				H
		87

86 87A
86 87A				85
30

RELAY

G F C

E

D A

B

29

Image 29

Contents Model NO. POGT20H48STA Safe Operation Practices for Ride-On Mowers IV. ServiceGeneral Operation II. Slope OperationSafety Rules Table of Contents Unassembled Parts Tools Required for Assembly AssemblyHOW to SET UP Your Tractor To Remove Tractor from CartonAssemble Gauge Wheels to Mower Deck See Fig Install Seat See FigInstall Mower and Drive Belt See Figs Check for Proper Position of ALL Belts Check Tire PressureCheck Mower Levelness Operation Know Your Tractor HOW to USE Your Tractor To Operate Mower See Fig To Adjust Gauge Wheels See FigTo Operate on Hills To Transport See FigsTowing Carts and Other ATTACH- Ments Before Starting the EngineCheck Engine OIL Level ADD GasolineAutomatic Transmission Warm UP Mowing TipsPurge Transmission Before Each USE MaintenanceGeneral Recommendations Tractor Engine Clean AIR INTAKE/COOLING Areas CleaningEngine OIL Filter MufflerTo Remove Mower See Fig Service and AdjustmentsTo Install Mower To Replace Mower Drive Belt To Level Mower HousingTo Replace Mower Blade Secondary Drive Belt See Fig To Check and Adjust Brake See FigTransmission REMOVAL/REPLACEMENT Transaxle Motion Control Lever Neutral Adjustment See FigBelt Installation To Replace Motion Drive Belt See FigTo Start Engine with a Weak Battery See Fig To Adjust Steering Wheel AlignmentReplacing Battery See Fig Front Wheel TOE-IN/CAMBERTo Replace Headlight Bulb To Adjust CarburetorInterlocks and Relays To Replace FuseFuel System OtherEngine OIL CylindersProblem Cause Correction Troubleshooting PointsOFF NON-REMOVABLE Removable Connections Connections SchematicTractor Model Number POGT20H48STA, Product no 56 Electrical KEY Part Description Chassis and Enclosures Repair Parts Drive Repair Parts Steering Assembly 159945 Engine Repair Parts 140117 Seat 140551 Bracket Pivot Seat 8 Seat AssemblyWheels & Tires DecalsMower Lift Repair Parts Mower Deck Repair Parts Limited Warranty Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe Operation