RedMax HEZ2650F manual Fuel, Gasoline Requirements, OIL Requirements, Warranty

Page 10

HEZ2650F

7. Fuel

■ FUEL

lines or fuel tank of the engine.

WARNING

•Gasoline is very flammable. Avoid smoking or bringing any flame or sparks near fuel. Make sure to stop the engine and allow it cool before refueling the unit. Select outdoor bare ground for fueling and move at least 10 ft (3 m) away from the fueling point before starting the engine.

■GASOLINE REQUIREMENTS

• All 2-Stroke RedMax Products are powered by Zenoah Professional-Commercial Duty, Hi-Performance, Hi-RPM, Air Cooled 2-Stroke engines.

RedMax/Zenoah – Hi-Performance 2-stroke engines produce higher HP outputs as compared to standard Home Owner Duty or Light Commercial Duty production engines offered by most manufacturers.

• Exhaust emission are controlled by the fundamental engine parameters and components (eq., carburation, ignition timing and port timing) without addition of any major hardware or the introduction of an inert material during combustion.

• The RedMax/Zenoah Engines are registered and certified with CARB (California Air Resources Board) and EPA (Environmental Protection Agency) to operate on CLEAN Mid- grade 89 octane or Premium, unleaded (lead-free) gasoline and RedMax Air-Cooled "Max Life", Synthetic blend Premium two- stroke engine oil mixed at 50:1 ratio.

• Unleaded gasoline is recommended to reduce the contamination of the air for the sake of your health and the environment.

• This Hi-Performance Air Cooled 2-stroke Engine requires the

use of Minimum 89 Octane [ R+M ] (Mid grade or Premium) 2

clean gasoline. Gasoline may contain maximum of 10% Ethanol (grain alcohol) or up to 15% MTBE (Methyl tertiary-butyl ether). Gasoline containing Methanol (Wood Alcohol) is NOT approved.

NOTE

•IF octane rating of the Mid Grade gasoline in your area is lower than 89 Octane use Premium Unleaded Gasoline. The majority of all 2-stroke engine manufacturers in the USA and Canada recommend using gasoline with 89 Octane or higher.

NOTE

•Failures caused by operating engines on gasoline with octane rating lower than 89 are not covered by the RedMax Two- Stroke engine warranty.

WARNING

•Alternative Fuels (Not Gasoline)

Alternative fuels, such as E-15 (15% ethanol), E-20 (20% ethanol), E-85 (85% ethanol) are NOT classified as gasoline and are NOT approved for use in RedMax 2-stroke gasoline engines. Use of alternative fuels will cause major engine performance and durability problems such as: improper clutch engagements, overheating, vapor lock, power loss, lubrication deficiency, deterioration of fuel lines, gaskets and internal carburetor components, etc... Alternative fuels cause high moisture absorption into the fuel/oil mixture leading to oil and fuel separation.

■OIL REQUIREMENTS

•Use only RedMax "Max Life", Synthetic blend Premium Air- Cooled two-stroke engine oil or oil certified to ISO-L-EGD (ISO/CD1378) standard AND one that is JASO-FD registered. RedMax Air-Cooled "Max Life", Synthetic blend Premium two stroke engine oil and ISO-L-EGD (ISO/CD1378) AND JASO-FD oils are fully compatible with gasoline's containing 10% Ethanol. RedMax Air-Cooled "Max Life", Synthetic blend Premium two stroke engine oil and ISO-L-EGD (ISO/CD1378) AND JASO-FD oils are Universal and should be mixed at 50:1 ratio for all 2 stroke air cooled engines sold in the past regardless of mixing ratios specified in those manuals.

•If the oil is registered with JASO, the JASO Logo with FD and registration number will be displayed on the container. The highest JASO rating is "FD", which equals the ISO-L-EGD rating. Lower ratings are "FC", "FB", and "FA".

•Engine problems due to inadequate lubrication caused by failure to use ISO-L-EGD certified and JASO FD registered oil such as "MaxLife", RedMax Synthetic blend Premium 2-stroke oil WILL VOID THE REDMAX TWO-STROKE ENGINE

WARRANTY.

WARNING

•Gasoline with an octane rating lower than 89 will greatly increase the engines operating temperature. Low octane gasoline will cause detonation (knock) resulting in piston seizures and major internal engine components damage.

•Poor quality gasolines or oils may damage sealing rings, fuel

US-10

WARNING

•Do not use NMMA (National Marine Manufacturers Association), BIA (Boating Industry Association), and TCW (two cycle water cooled) oils designed for MoPeds or Outboard, water cooled Marine Engines. Do not use API (American Petroleum Institute), TC (Two Cycle) labeled oils. The API-TC

Page 9 Page 11
Image 10
Page 9 Page 11
Contents HEZ2650F Contents Specifications Parts locationEmission Control Symbols on the machineManufactured For safe operation Before use Using the productStarting the engine Maintenance Fuel safetyAvoid noise problem TransportDisposal SE1 Set upMounting Other Parts SE2Fuel WarrantyFuel Gasoline RequirementsFor Your Engine LIFE, Avoid HOW to MIX Fuel Recommended Mixing Ratio Gasoline 50 OILFueling the Unit Operation Adjusting Idling Speed OP7 OP8 HOW to USEAdjusting Throttle Cable Stopping Engine OP4Maintenance Maintenance ChartMuffler Replacement Plug is a NGK CMR7HMA1 AIR Filter MA4MA8 MA9 Procedures to be Performed After Every 100 Hours of USEMA7 Blade MA7 ProtectorDisposal Troubleshooting guideStorage Case 1. Starting failureZenoah AMERICA, INC

HEZ2650F specifications

The RedMax HEZ2650F is a high-performance, lightweight backpack blower designed for professionals and homeowners who require an efficient and powerful tool for yard maintenance and landscaping tasks. Built to excel in various conditions, this versatile blower combines advanced technology with user-friendly features, making it a top choice in the market.

One of the standout features of the HEZ2650F is its robust engine. Powered by a reliable 25.4cc two-stroke engine, the blower delivers an impressive air velocity of up to 180 mph, providing the power needed to clear leaves, debris, and grass clippings with ease. The engine is designed to be fuel-efficient, allowing for longer run times without frequent refueling, making it ideal for extended work sessions.

The innovative Design of the HEZ2650F incorporates RedMax's advanced air flow technology. This technology optimizes the air intake and exhaust systems, ensuring that the blower operates at maximum efficiency. As a result, users can expect powerful performance without sacrificing fuel economy, which is crucial for both commercial users and dedicated homeowners.

Comfort is another key consideration in the design of the HEZ2650F. The backpack design distributes weight evenly across the user's back, significantly reducing fatigue during prolonged use. Additionally, the padded shoulder straps and ergonomic handle provide added comfort, allowing users to maneuver the blower effortlessly in tight spaces.

The blower is equipped with a cruise control feature that enables users to maintain a consistent airflow without having to hold down the throttle trigger constantly. This feature enhances productivity and allows for longer periods of operation without fatigue. Moreover, the lightweight construction of the HEZ2650F makes it easier to handle, even for those who may not be accustomed to operating heavy machinery.

Durability is also a hallmark of the RedMax HEZ2650F. Its rugged design is built to withstand the rigors of professional use, ensuring that it can handle tough landscaping tasks season after season. The blower's components are crafted from high-quality materials that resist wear and tear, enhancing its longevity.

In summary, the RedMax HEZ2650F is an outstanding backpack blower that combines a powerful engine, advanced air flow technology, and user-focused features. With its lightweight design, comfort enhancements, and durable construction, it stands out as one of the best options for anyone looking to maintain their outdoor spaces efficiently. Whether for professional landscapers or dedicated homeowners, the HEZ2650F is a reliable choice for effective yard care.
Top Page Image Contents