Zenoah RMSZ2500 manual MA1, End cap Main gear

Page 24

9. Maintenance

MA1

1.Remove the drum and axle assemblies (see page 13), and then remove the four end cap bolts and the end cap (the gearcase need not be removed from the RedMax Sweeper).

2.Allow all used gearcase oil to drain into a small container.

WARNING

BURN DANGER! The gearcase and oil will be extremely hot after use!

3.Place the RedMax Sweeper main gear flat. Refill the gearcase with Mobil SHC 634 Synthetic Gear Oil to the top of the main gear (60ml – 1.80zs), as shown. DO NOT OVERFILL! (MA1)

(1)End cap

(2)Main gear

4.Apply a continuous bead of loctite ultra grey around the pilot diameter of the end cap. Install the end cap, and then install and firmly tighten the four end cap bolts.

5.Install the drum and axle assemblies, and then reconnect the spark plug wire.

IMPORTANT

•Use only Mobil SHC 634 Synthetic Gear Oil.

•Do not mix other oils ar additives with the RedMax Sweeper Gearcase Oil.

•Do not disturb the sealed end plug or bolt on the gearcase (leakage may occur).

•Do not use the RedMax Sweeper if oil is leaking from the gearcase. Return the machine to the dealer for repairs.

24 

Image 24

Contents RMSZ2500 RMS9-99102Page Safety First ContentsParts location Specifications RMSZ2500Avertissement Symbols on the machine Important Engine InformationFor safe operation Working ConditionWorking Circumstance Working Plan Before Starting the Engine Starting the EngineUsing the Product Use only for tasks explained in the manualMaintenance If Someone ComesHandling Fuel Transportation Set up SE4 Sweeper Assembly SE4 Clevis Pin Hitch Pin Cotter Pin Drum Axle Drum AssemblyHOW to MIX Fuel FuelRecommended Mixing Ratio Gasoline 50OIL Fueling the Unit For Your Engine LIFE, AvoidOperation OP1OP21 OP3 OP4 Starting EngineAdjusting Throttle Cable Adjusting Idling Speed OP6OP5 OP6 OP7 Stopping Engine OP3OP8 OP9 Direction of rotation Operating and Safety Tips OP11 OP10 OP11 Maintain a shallow angle to the work surface YOU Must Always Guard Against Thrown DebrisGeneral Safety Instructions Never make unauthorized attachment installations Stay AlertLoad Avoid low rpm operationMaintenance Maintenance ChartGearcase Lubrication MA1 End cap Main gearReplacement Plug is a NGK CMR7A MA2 MA3 MA4AIR Filter Fuel FilterMA5 MufflerSpark Arrester Spark ArresterProcedures to be Performed After Every 100 Hours of USE MA61MA7 Cylinder Intake Air Cooling Vent backTroubleshooting guide StorageCheck Probable Causes Action Parts list RMSZ2500  31   32   33  Limited Warranty RedMax Garantie limitée Komatsu Zenoah America INC