Troy-Bilt 634BM, 634FM manual Form no -10594C, 11/25/02

Page 1

OTRO_ BILT

Operator's Manual

Rear-tine Tiller Models

630C Tuffy_

634Fm BroncoTM

634Bm Super BroncoTM

Model 634B Shown

IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY

WARNING: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-

covered, brush-covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator. In the State of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 361131 Cleveland, Ohio 44136-0019.

TROY-BILT LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019

PRINTEDIN U.S.A.

FORM NO. 770-10594C

 

11/25/02

Image 1
Contents 11/25/02 Form no -10594CTableofcontents Training SafetyPreparation ForwardClutchBReverseClutchControl Models634F/634BKeepchildren and petsaway MaintenanceandStorageReverseClutchControl DecalsModels634F/634B StartingStabilization Messageon engine LoosePartsList AssemblyClutch Cable Install ForwardFlat Side Install Reverse Clutch Cable Models 634F & 634B only31bY I Liielklevel UI CheckhardwareIbY I AUU Muiuh UIL Check AIR PressureWheel Drive Pins FeaturesandcontrolsIntroduction Engine ControlsForwardclutchbail Handlebar Height AdjustmentDepth Regulator Lever ReverseclutchcontrolStartingandstopping OperationBREAK-IN Operation Stoppingthe Engineand Tiller Operatingthe TillerStoppingthe TillerandEngine AvoidTilling Soggy,Wet Soil TillingLee passes Tilling AcrossSlopesWithout UsingTerracesHorizontalTillingAllureo follow tins warmng Readthe following recommendationsbeforetilling on slopesUnloadingthe tiller into LoadingandunloadingTransmission Gearoil Service MaintenanceMaintenance Schedule Procedure CheckforoilleaksTo Drain the TransmissionGear Oil Removinnstalling a Tine AssemblyBolo Tines Removinnstalling a Single TineReplacementBelt Information Adjusted, reattach the spring to the For- ward Clutch BalChecking and Adjusting Forward Drive Belt Tension To CheckForwardBelt TensionEnginecleaning BailadjustmentAircleanerservice EngineoilserviceThrottleleveradjustment SparkplugserviceStore unit in a clean, dry area OFF-SEASONSTORAGEProblempossiblecause Correction TroubleshootingAForModel630C MODELS630C,634F & 634B PartslistBForModel634F CForModel634BMODELS630C, 634F & 634B 1916719 1916755 1917479 1918745 710-0599 710-3008 712-3009 Partno DescriptionGW-55042 GW-55043 10 GW-55102 11 GW-55044 12 GW-9855GW-1224-3 AForModel6300 BForModel634F CForModel634BGW-1224-4 GW-13250 ShimSetIncLthefollowingshimsGW-9512 GW-9727 Plug,TransmissionOilFill 721-04031 GW-50032 Gasket,HousingCover 710-04048710-04049 619-04013LEFT-HANDTINE RIGHT-HANDTINE MODELS6300,634F & 634BMODELS630C, 634F & 634B MODELS630C, 634F & 634B TROY-BILT Tiller Lifetime Limited Warranty