Multiquip manual MVH-150D2 Inspection, Before Starting, Engine Oil Check, Fuel Check

CAUTION - General Safety Precautions

NEVER operate the compactor in a confined area or enclosed area structure that does not provide ample free flow of air.

ALWAYS wear approved eye and hearing protection before operating the compactor.

Before Starting:

1.Read safety instructions at the beginning of manual.

2.Remove dirt and dust, particularly in the engine cooling air inlet, carburetor and air cleaner.

3.Check the air filter for dirt and dust.

If air filter is dirty, replace air filter with a new one as required.

4.Check carburetor for external dirt and dust. Clean with dry compressed air.

5.Check fastening nuts and bolts for tightness.

Engine Oil Check:

1.To check the engine oil level, place the compactor on secure level ground with the engine stopped.

2.Remove the filler dipstick from the engine oil filler hole (Figure 5) and wipe clean.

Figure 5. Engine Oil Dipstick (Removal)

MVH-150D2 — INSPECTION

3.Insertandremovethedipstickwithoutscrewingitintothefiller neck. Check the oil level shown on the dipstick.

4.If the oil level is low (Figure 6), fill to the edge of the oil filler hole with the recommended oil type (Table 4).Maximum oil capacity is 0.84 quarts (0.80 liters).

Figure 6. Engine Oil Dipstick (Oil Level)

DANGER - Explosive Fuel

Diesel is extremely flammable, and its vapors can cause an explosion if ignited. DO NOT start the engine near spilled fuel or combustible fluids. DO NOT smoke while refueling. DO NOT attempt to refuel the compactor if the engine is hot! or running.

Fuel Check:

1.Remove the fuel cap located on top of fuel tank.

2.Visually inspect to see if the fuel level is low. If fuel is low, replenish with clean diesel fuel.

3.Whenrefueling,besuretouseastrainerforfiltration.DONOT top-off fuel.Wipe up any spilled fuel immediately!

MVH-150D2 PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #2 (01/16/07) — PAGE 15