Sears 153333130 Sediment Trap, GAS Piping with ALL Black Iron Pipe To GAS Control, Ground JOINTi

Page 14

Piping,

WARNING

Make sure the gas suppliedis the same type listed on the model rating plate, The inlet gas pressure must not exceed 14 inches water column [Y2 pound per square inch (3o5kPa)]o The minimum inlet gas pressure "listed on the model rating plate is for the purposeoJ'input adjustment.

WARNING

If the gascontrolvalveis subjectedto pressuresexceedingt/_ pound-persquare inch (3.5kPa), the damageto the gascon- trol valvecouldresultin a fire or explosion from leakl'nggas°

WARNING

If the main gaslineshutoff servingall gasappliancesis used, alsoturn "OFF" thegasat eachappliance.Leaveall gasappli- ancesshutoff until thewater heaterinstallationiscomplete°

A gas line of sufficient size must be run to the water heater. Consult the latest edition of National Fuel Gas Code ANSI Z223 1, also referred to as NFPA54 and the gas company concerning pipe size

There must be:

WARNING

Use pipe joint compound or teflon tape marked as being resistantto the action of petroleum [Propane (LP,)] gases_

SEDIMENT TRAP

A sediment trap shall be installed as close to the inlet of the water heater as practical at the time of water heater installation The sediment trap shall be either a tee fitting with a capped nipple in the bottom outlet or other device recognized as an effective sediment trap. If a tee fitting is used, it shall be installed in conformance with one of the methods of installation shown below.

Connectingthe gaspiping to the gascontrol valve of the water heatercan be accomplishedby either of the two methodsshown

GAS PIPING WITH FLEXIBLE CONNECTOR

_._ GAS SUPPLY PIPING

MANUAL J_1'

SHUTOFFli_

VALVE

_ FLEXIBLE GAS CONNECTOR

LABELEDAS COMPLYING

WITHANSI STANDARDS

-A readily accessible manual shut off valve in the gas sup-

GROUND

LOOP

ply line serving the water heater, and

-A drip leg (sediment trap) ahead of the gas control valve to help prevent dirt and foreign materials from entering the gas control valve

-A flexible gas connector or a ground joint union between the shutoff valve and control valve to permit servicing of the unit

Be sure to check all the gas piping for leaks before lighting the water heater Use a soapy water solution, not a match or open flame. Rinse off soapy solution and wipe dry

Standard Models are for installation up to 3,300 feet above sea level.

High Altitude Models are for installation from 3,300 to 5,500 feet above sea level

If a standard model is installed above 3,300 feet or a high altitude model is installed above 5,500 feet, the input rat-

ing must be reduced at the rate of 4 percent for each 1,000 feet above sea level. Contact your local Sears Service Center or gas utility for further information

WARNING

I Theed bef(appliancereplacingandtheits appliancegas connectionin operationmust be. leak test-

...........WARNING. ......

The appliance and its individual shutoff valve must be discon- nected from the gas supply piping systemduring any pressure testing of that system at test pressures in excess of'h pound per square inch (3_5kPa).

The appliance must be isolated from the gas supplypiping sys- tem by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pres- sures equal to or lessthan =/2pound per square inch (3.5kPa).

UNION (Optional)

GAS

CONTROL

VALVE

GAS PIPING WITH ALL BLACK IRON PIPE

TO GAS CONTROL

PIPING

SHUTOFF

MANUALVALVE _GAS SUPPLY

 

_[_

BLACKPIPE

GROUND JOINTi_

/

 

 

GAS

UNION

__

CONTROL

 

 

VALVE

.........WARNING .............-

Contaminants in the gas lines may cause improper operation

of the gas control valve that may result in fire or explosion. Before attaching the gas line be sure that all gas pipe is clean on the inside. To trap any dirt or foreign material in the gas supply line, a drip [eg (sometimes caJled a sediment trap)

must be incorporate([ in the pipings"The drip. leg must, be readily accessible, install in accordance with the Gas

Piping_'section. Refer to the latest edition of the National

Fuel Gas Code, ANSI Z223_1, also referred to as NFPA 54.

13

Page 13 Page 15
Image 14
Page 13 Page 15
Contents Save this Manual for Future Reference Whatto do if YOU Smell GASDEATH, Serious Bodily INJURY, or MODEl- NumbersThis may reducethe changesof flammablevaporsfrom a floor Before Lighting Propane L,RGAS Water HEATER5Water damagein connection with this water heater Thiswaterheatermust not be installed directly on carpetingPound-persquare inch 35kPa General Height to Tank TypeMinimum CapacityYou may or may not need all of these tools, depending on OTurn ItOFF the gas supply to the water heater Minimum clearances between the water heater and com This water heater must not be installed directly on carpetFacts to Consider About the Location Allair from Inside Buildings Searsinstallation KIT Shutoff Water PipingTemperature-Pressure Relief Valve Charge capacity of the valveTion, explosionor asphyxiation Sears Service Center or gas utility for further informationFilling the Water Heater Lslopeupwardto thechimneyat least1,inchper linear footInstallation Checklist Model Rating PlateGround JOINTi Sediment TrapGAS Piping with ALL Black Iron Pipe To GAS Control For Your SAFETYFigure Before Lighting Propane LP. GAS WaterControlsystemand any gas controlwhichhas been underwater Somegasis heavierthanair andwillsetUeon thefloorWhatto Doif Yousmellgas Not ForceHotterwatercan SCALDWater heatersare intended to SMOKE/ODOR Operational ConditionsCondensation Strange SoundsNot Enough or no HOT Water High Temperature Shut OFF SystemAIR in HOT Water Faucets Burner Inspection Burner CleaningVenting System Inspection HousekeepingTemperature-Pressure Relief Tank Sediment €leaningPage Page 17 i 0270118 KEYT53.333031 153.333100 #40 #41HA153.333131 40 Gal 53333530 50 Ga 153.333531 50 Gal #38 Model NumbersPart Numbers 153o333131 40 GaL 153.333530 50 Gal 153.333531 50 GaLAbout Your Warranty Sears Installation Policy Sears Installation Warranty

153333030, 153333100, 153333130, 153333531, 153333000 specifications

Sears has long been a staple in the retail industry, and its product line reflects a commitment to quality and innovation. The following details highlight the main features, technologies, and characteristics of five specific model numbers: 153333530, 153333131, 153333031, 153333000, and 153333531.

The Sears model 153333530 is designed with durability and functionality in mind. One of its standout features is an ergonomically designed handle that provides a comfortable grip, making it user-friendly for extended periods of use. This model also incorporates advanced safety mechanisms, ensuring a secure operation that minimizes the risk of accidents.

Meanwhile, the 153333131 model offers versatility and efficiency. It comes equipped with multiple settings that allow users to customize their experience according to their specific needs. This adaptability is further enhanced by its smart technology, which can optimize performance based on the task at hand, providing a seamless user experience.

The 153333031 model aims to combine power with convenience. It boasts a robust motor that delivers impressive performance for various tasks. This model is further characterized by its lightweight design, which makes it easy to maneuver, especially in tight spaces. Additionally, it includes an energy-efficient feature that helps reduce power consumption without compromising on effectiveness.

With the model 153333000, Sears emphasizes portability and compactness. This unit is specifically designed for users who require a product that is easy to transport. Its folding mechanism allows for efficient storage, making it perfect for those with limited space. The model also incorporates modern technology, such as Bluetooth connectivity, enabling users to control it remotely through a smartphone application.

Lastly, the Sears 153333531 model stands out due to its environmentally friendly design. This model utilizes sustainable materials that reduce its carbon footprint while maintaining high quality and reliability. Its advanced filtration system not only enhances performance but also contributes to a healthier home environment.

In summary, these Sears models showcase diverse features and technologies aimed at enhancing user convenience, safety, and performance. By focusing on ergonomics, versatility, power, portability, and sustainability, Sears continues to meet the evolving needs of consumers while also championing innovation in the retail space.
Top Page Image Contents