Multiquip N/A manual HTH Controls and Indicators

Page 17

HTH — CONTROLS AND INDICATORS

27.Oil Filter – Provides oil filtering for the engine.

28.Retardant Spray Motor – Used with the spray control button.

29.Retardant Spray Tank - Holds 5 gallons of retardant or water.

30.Battery - Provides +12V DC power to the electrical sys- tem.

31.Hydraulic Suction Filter - Filters hydraulic fluid prior to entering the system.

32.Hydraulic Return Filter - Filters hydraulic returning to reservoir.

NOTE

Read this entire instruction manual completely before attempt- ing to operate this machine.

The following section is intended as a basic guide to the ride-on trowel operation, and is not to be considered a complete guide to concrete finishing. It is strongly suggested that all operators (experienced and novice) read “Slabs on Grade” published by the American Concrete Institute, Detroit Michigan.

HTH-8 FT. RIDE-ON POWER TROWEL — OPERATION AND PARTS MANUAL — REV. #6 (02/22/11) — PAGE 17

Image 17

Contents HTH-SERIES Proposition 65 Warning SILICOSIS/RESPIRATORY Warnings Table of Contents Ordering parts has never been easier Parts Ordering ProceduresComments Training ChecklistComments Daily PRE-OPERATION ChecklistSafety Messages Safety InformationSafety Information Trowel Safety Fuel Safety Towing Safety Environmental Safety HTH Specifications HTH SpecificationsHTH General Information HTH Controls and Indicators HTH Controls and Indicators Engine Oil HTH Initial START-UPHTH Initial START-UP Blade Speed Control Foot Pedal HTH Maintenance Blade Pitch Adjustment Procedure HTH MaintenancePressure Gauge Hydraulic Pump HTH Troubleshooting Symptom Possible Problem Solution MQ-45T only Explanation of Code in Remarks ColumnSWITCH, Light Switch Ignition VanguardBOOT, Switch Battery CableHTH LEFT/RIGHT Pivot Assy HTH LEFT/RIGHT Pivot Assy HTH LEFT/RIGHT Pivot Assy HTH Note HTH LEFT/RIGHT Twin Pitch Assy HTH LEFT/RIGHT Twin Pitch Assy LEFT/RIGHT Twin Pitch Assy HTH LEFT/RIGHT Twin Pitch AssyMiter BOX Assy SHAFT, Miter BOX HorizDECAL, AL PITCH, RH DECAL, AL PITCH, LHHTH Engine Vanguard HTH Engine Vanguard HTH Engine Vanguard HTH Note HTH Engine Kubota HTH Engine Kubota Engine Kubota HTH Note HTH Engine Kubota below S/N JG53027 Engine Kubota below S/N JG53027 HTH Engine Kubota below S/N JG53027HTH Hydraulic Steering Assy Hydraulic Steering Assy HTH Hydraulic Steering AssyHTH Valve Assy Left Side Valve Assy Left Side Valve Assy Right Side HTH Valve Assy Right SideCLAMP, Boot Housing ValveHANDLE, Right Valve Bolt ASSY, PivotHTH Handle Assy Left Side Handle Assy Left Side HTH Handle Assy Left SideHTH Hydraulic Drive Assy HTH Hydraulic Drive Assy Hydraulic Drive Assy HTH Hydraulic Drive AssyFITTING, 45 6MJ-8MO FITTING, STR 8MJ-3/8 MPFITTING, 90 1 MP-3/4 FP Swiv FITTING, Nipple 1 MP CloseHTH 4-BLADE Spider Left Assy Blade Spider Left Assy HTH 4-BLADE Spider Left AssyHTH 4-BLADE Spider Right Assy Blade Spider Right Assy HTH 4-BLADE Spider Right AssyHTH Conversion 4-BLADE to 5-BLADE HTH Note HTH 5-BLADE Spider Assy Left Left Side Spider Assembly 5-BLADE View from Operators SeatBlade Spider Assy Left HTH 5-BLADE Spider Assy Right Blade Spider Assy Right HTH 5-BLADE Spider Assy RightLEVER, Trowel ARM Right Side SPRING, Right TrowelStabilizer Ring Assy HTH Stabilizer Ring Assy1237 TOP Panel Left Side HTH TOP Panel Left SidePANEL, TOP Left PANEL, Front LeftPANEL, Radiator Cover HINGE, PanelTOP Panel Right Side HTH TOP Panel Right SideBULB, Indicator Light SWITCH, KillPLUG, Indicator Light OIL, WATER, Charge RED DECAL, CHOKE/LIGHT KEY SwitchFront Panel Right Vanguard HTH Front Panel Right VanguardKEY, Ignition Switch SWITCH, Ignition W/KEYSLight Switch BOOT, Light SwitchKubota only Front Panel Right Kubota HTH Front Panel Right KubotaUniversal KEY SET Accesory SolenoidSeat and Frame HTH Seat and FrameSeat W/ARMS FRAME, Seat W/APLATE, Seat W/A PANEL, Front CenterFrame and Fuel Tank HTH Frame and Fuel TankFuel CAP/GAUGE DECAL, MQ WHITEMAN, 23 1/2FRAME, Complete Foot REST, LeftFoot Pedals HTH Foot PedalsCABLE, Throttle Assy Accelerator Pedal W/ABOLT, Cable ROD END, 1/4 28 Female RHBattery HTH BatteryBattery Part Name QTY. Remarks Spray Assy HTH Spray AssyWire ASSY, Pump BUSING, Rubber Fuel DapcoWASHER, FLAT, 1/4 SAE Incls Item W PUMP, Spray KITLight Assy HTH Light AssyBRACKET, Light Mover and Lift Handle HTH E-Z Mover and Lift HandleUpper Handle Hand GripSnap PIN ClipHTH Wiring Diagram Vanguard HTH Wiring Diagram Kubota Terms and Conditions of Sale Parts Page HERE’S HOW to GET Help