Multiquip N/A manual HTH Valve Assy Left Side

Page 48

HTH — VALVE ASSY (LEFT SIDE)

2

20

4 22

5

18

131

21

7

12

1911

7

106

184

6

7

3

9

6

2 14 15

PORT "A"

17

5 16

3

82

NOTES:

PORT "B"	1	TORQUE TO 48	+	5 FT. LBS
PORT "B"

2TORQUE TO 33 + 3.5 FT. LBS

3TORQUE TO 14 + 1.5 FT. LBS

4TORQUE TO 7 + 1.0 FT. LBS

5TORQUE TO 18 + 2.0 FT. LBS

6FOR COMPLETE VALVE ASSY. USE PART NUMBER 11423.

7LUBRICATE PIVOT JOINT, PLATE AND PLUNGER CONTACT AREAS AS REQUIRED.

8FOR LEFT HANDLE PARTS BREAK- DOWN SEE PAGE 46.

PAGE 48 — HTH-8 FT. RIDE-ON POWER TROWEL — OPERATION AND PARTS MANUAL — REV. #6 (02/22/11)

Image 48

Contents HTH-SERIES Proposition 65 Warning SILICOSIS/RESPIRATORY Warnings Table of Contents Parts Ordering Procedures Ordering parts has never been easierTraining Checklist CommentsDaily PRE-OPERATION Checklist CommentsSafety Information Safety MessagesSafety Information Trowel Safety Fuel Safety Towing Safety Environmental Safety HTH Specifications HTH SpecificationsHTH General Information HTH Controls and Indicators HTH Controls and Indicators HTH Initial START-UP Engine OilHTH Initial START-UP Blade Speed Control Foot Pedal HTH Maintenance HTH Maintenance Blade Pitch Adjustment ProcedurePressure Gauge Hydraulic Pump HTH Troubleshooting Symptom Possible Problem Solution Explanation of Code in Remarks Column MQ-45T onlySwitch Ignition Vanguard SWITCH, LightBOOT, Switch Battery CableHTH LEFT/RIGHT Pivot Assy HTH LEFT/RIGHT Pivot Assy HTH LEFT/RIGHT Pivot Assy HTH Note HTH LEFT/RIGHT Twin Pitch Assy HTH LEFT/RIGHT Twin Pitch Assy HTH LEFT/RIGHT Twin Pitch Assy LEFT/RIGHT Twin Pitch AssySHAFT, Miter BOX Horiz Miter BOX AssyDECAL, AL PITCH, RH DECAL, AL PITCH, LHHTH Engine Vanguard HTH Engine Vanguard HTH Engine Vanguard HTH Note HTH Engine Kubota HTH Engine Kubota Engine Kubota HTH Note HTH Engine Kubota below S/N JG53027 HTH Engine Kubota below S/N JG53027 Engine Kubota below S/N JG53027HTH Hydraulic Steering Assy HTH Hydraulic Steering Assy Hydraulic Steering AssyHTH Valve Assy Left Side Valve Assy Left Side HTH Valve Assy Right Side Valve Assy Right SideHousing Valve CLAMP, BootHANDLE, Right Valve Bolt ASSY, PivotHTH Handle Assy Left Side HTH Handle Assy Left Side Handle Assy Left SideHTH Hydraulic Drive Assy HTH Hydraulic Drive Assy HTH Hydraulic Drive Assy Hydraulic Drive AssyFITTING, STR 8MJ-3/8 MP FITTING, 45 6MJ-8MOFITTING, 90 1 MP-3/4 FP Swiv FITTING, Nipple 1 MP CloseHTH 4-BLADE Spider Left Assy HTH 4-BLADE Spider Left Assy Blade Spider Left AssyHTH 4-BLADE Spider Right Assy HTH 4-BLADE Spider Right Assy Blade Spider Right AssyHTH Conversion 4-BLADE to 5-BLADE HTH Note Left Side Spider Assembly 5-BLADE View from Operators Seat HTH 5-BLADE Spider Assy LeftBlade Spider Assy Left HTH 5-BLADE Spider Assy Right HTH 5-BLADE Spider Assy Right Blade Spider Assy RightLEVER, Trowel ARM Right Side SPRING, Right TrowelHTH Stabilizer Ring Assy Stabilizer Ring Assy1237 HTH TOP Panel Left Side TOP Panel Left SidePANEL, Front Left PANEL, TOP LeftPANEL, Radiator Cover HINGE, PanelHTH TOP Panel Right Side TOP Panel Right SideSWITCH, Kill BULB, Indicator LightPLUG, Indicator Light OIL, WATER, Charge RED DECAL, CHOKE/LIGHT KEY SwitchHTH Front Panel Right Vanguard Front Panel Right VanguardSWITCH, Ignition W/KEYS KEY, Ignition SwitchLight Switch BOOT, Light SwitchKubota only HTH Front Panel Right Kubota Front Panel Right KubotaUniversal KEY SET Accesory SolenoidHTH Seat and Frame Seat and FrameFRAME, Seat W/A Seat W/ARMSPLATE, Seat W/A PANEL, Front CenterHTH Frame and Fuel Tank Frame and Fuel TankDECAL, MQ WHITEMAN, 23 1/2 Fuel CAP/GAUGEFRAME, Complete Foot REST, LeftHTH Foot Pedals Foot PedalsAccelerator Pedal W/A CABLE, Throttle AssyBOLT, Cable ROD END, 1/4 28 Female RHHTH Battery BatteryBattery Part Name QTY. Remarks HTH Spray Assy Spray AssyBUSING, Rubber Fuel Dapco Wire ASSY, PumpWASHER, FLAT, 1/4 SAE Incls Item W PUMP, Spray KITHTH Light Assy Light AssyBRACKET, Light HTH E-Z Mover and Lift Handle Mover and Lift HandleHand Grip Upper HandleSnap PIN ClipHTH Wiring Diagram Vanguard HTH Wiring Diagram Kubota Terms and Conditions of Sale Parts Page HERE’S HOW to GET Help