Multiquip N/A manual Safety Information, Safety Messages

Page 8

Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment.

Failure to read and understand the safety messages and operating instructions could result in injury to yourself and others.

SAFETY MESSAGES

The four safety messages shown below will inform you about potential hazards that could injure you or others.The safety messages specifically address the level of exposure to the operator and are preceded by one of four words: DANGER, WARNING, CAUTION or NOTICE.

SAFETY SYMBOLS

DANGER

Indicates a hazardous situation which, if not avoided, WILL result in DEATH or SERIOUS INJURY.

WARNING

Indicates a hazardous situation which, if not avoided, COULD result in DEATH or SERIOUS INJURY.

CAUTION

Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY.

NOTICE

Addresses practices not related to personal injury.

SAFETY INFORMATION

Potential hazards associated with the operation of this equipment will be referenced with hazard symbols which may appear throughout this manual in conjunction with safety messages.

Symbol

Safety Hazard

Lethal exhaust gas hazards

Explosive fuel hazards

Burn hazards

Rotating parts hazards

Pressurized fluid hazards

Hydraulic fluid hazards

PAGE 8 — HTH-8 FT. RIDE-ON POWER TROWEL — OPERATION AND PARTS MANUAL — REV. #6 (02/22/11)

Image 8

Contents HTH-SERIES Proposition 65 Warning SILICOSIS/RESPIRATORY Warnings Table of Contents Parts Ordering Procedures Ordering parts has never been easierTraining Checklist CommentsDaily PRE-OPERATION Checklist CommentsSafety Information Safety MessagesSafety Information Trowel Safety Fuel Safety Towing Safety Environmental Safety HTH Specifications HTH SpecificationsHTH General Information HTH Controls and Indicators HTH Controls and Indicators HTH Initial START-UP Engine OilHTH Initial START-UP Blade Speed Control Foot Pedal HTH Maintenance HTH Maintenance Blade Pitch Adjustment ProcedurePressure Gauge Hydraulic Pump HTH Troubleshooting Symptom Possible Problem Solution Explanation of Code in Remarks Column MQ-45T onlySwitch Ignition Vanguard SWITCH, LightBOOT, Switch Battery CableHTH LEFT/RIGHT Pivot Assy HTH LEFT/RIGHT Pivot Assy HTH LEFT/RIGHT Pivot Assy HTH Note HTH LEFT/RIGHT Twin Pitch Assy HTH LEFT/RIGHT Twin Pitch Assy HTH LEFT/RIGHT Twin Pitch Assy LEFT/RIGHT Twin Pitch AssySHAFT, Miter BOX Horiz Miter BOX AssyDECAL, AL PITCH, RH DECAL, AL PITCH, LHHTH Engine Vanguard HTH Engine Vanguard HTH Engine Vanguard HTH Note HTH Engine Kubota HTH Engine Kubota Engine Kubota HTH Note HTH Engine Kubota below S/N JG53027 HTH Engine Kubota below S/N JG53027 Engine Kubota below S/N JG53027HTH Hydraulic Steering Assy HTH Hydraulic Steering Assy Hydraulic Steering AssyHTH Valve Assy Left Side Valve Assy Left Side HTH Valve Assy Right Side Valve Assy Right SideHousing Valve CLAMP, BootHANDLE, Right Valve Bolt ASSY, PivotHTH Handle Assy Left Side HTH Handle Assy Left Side Handle Assy Left SideHTH Hydraulic Drive Assy HTH Hydraulic Drive Assy HTH Hydraulic Drive Assy Hydraulic Drive AssyFITTING, STR 8MJ-3/8 MP FITTING, 45 6MJ-8MOFITTING, 90 1 MP-3/4 FP Swiv FITTING, Nipple 1 MP CloseHTH 4-BLADE Spider Left Assy HTH 4-BLADE Spider Left Assy Blade Spider Left AssyHTH 4-BLADE Spider Right Assy HTH 4-BLADE Spider Right Assy Blade Spider Right AssyHTH Conversion 4-BLADE to 5-BLADE HTH Note Left Side Spider Assembly 5-BLADE View from Operators Seat HTH 5-BLADE Spider Assy LeftBlade Spider Assy Left HTH 5-BLADE Spider Assy Right HTH 5-BLADE Spider Assy Right Blade Spider Assy RightLEVER, Trowel ARM Right Side SPRING, Right TrowelHTH Stabilizer Ring Assy Stabilizer Ring Assy1237 HTH TOP Panel Left Side TOP Panel Left SidePANEL, Front Left PANEL, TOP LeftPANEL, Radiator Cover HINGE, PanelHTH TOP Panel Right Side TOP Panel Right SideSWITCH, Kill BULB, Indicator LightPLUG, Indicator Light OIL, WATER, Charge RED DECAL, CHOKE/LIGHT KEY SwitchHTH Front Panel Right Vanguard Front Panel Right VanguardSWITCH, Ignition W/KEYS KEY, Ignition SwitchLight Switch BOOT, Light SwitchKubota only HTH Front Panel Right Kubota Front Panel Right KubotaUniversal KEY SET Accesory SolenoidHTH Seat and Frame Seat and FrameFRAME, Seat W/A Seat W/ARMSPLATE, Seat W/A PANEL, Front CenterHTH Frame and Fuel Tank Frame and Fuel TankDECAL, MQ WHITEMAN, 23 1/2 Fuel CAP/GAUGEFRAME, Complete Foot REST, LeftHTH Foot Pedals Foot PedalsAccelerator Pedal W/A CABLE, Throttle AssyBOLT, Cable ROD END, 1/4 28 Female RHHTH Battery BatteryBattery Part Name QTY. Remarks HTH Spray Assy Spray AssyBUSING, Rubber Fuel Dapco Wire ASSY, PumpWASHER, FLAT, 1/4 SAE Incls Item W PUMP, Spray KITHTH Light Assy Light AssyBRACKET, Light HTH E-Z Mover and Lift Handle Mover and Lift HandleHand Grip Upper HandleSnap PIN ClipHTH Wiring Diagram Vanguard HTH Wiring Diagram Kubota Terms and Conditions of Sale Parts Page HERE’S HOW to GET Help