Stow MS-70 manual Burn Hazards, Respiratory Hazards

Page 8

STOW MS-70 MIXER — SAFETY MESSAGE ALERT SYMBOLS

FOR YOUR SAFETY AND THE SAFETY OF OTHERS!

HAZARD SYMBOLS

Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others.

This Owner's Manual has been developed to provide complete instructions for the safe and efficient

NOTE operation of the STOW Model MS-70mortar and plaster mixer. Refer to the engine manufacturers instructions for data relative to its safe operation.

Before using this mixer, ensure that the operating individual has read and understands all instructions in this manual.

SAFETY MESSAGE ALERT SYMBOLS

The three (3) Safety Messages shown below will inform you about potential hazards that could injure you or others. The Safety Messages specifically address the level of exposure to the operator, and are preceded by one of three words: DANGER,

DANGER

You WILL be KILLED or SERIOUSLY INJURED

if you DO NOT follow these directions.

WARNING

You CAN be KILLED or SERIOUSLY INJURED if you DO NOT follow these directions.

CAUTION

You CAN be INJURED if you DO NOT follow these directions.

Potential hazards associated with the operation of a MS-70 Plaster/Mortar Mixer will be referenced with Hazard Symbols which appear throughout this manual, and will be referenced in conjunction with Safety Message Alert Symbols.

WARNING Lethal Exhaust Gas Hazards

Engine exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled. NEVER operate this equipment in a confined area or enclosed structure that does not provide ample free flow air.

WARNING Explosive Fuel Hazards

Gasoline is extremely flammable, and its vapors can cause an explosion if ignited. DO NOT start the engine near spilled fuel or combustible fluids.

DO NOT fill the fuel tank while the engine is running or hot. DO NOT overfill tank, since spilled fuel could ignite if it comes into contact with hot engine parts or sparks from the ignition system. Store fuel in approved containers, in well-ventilated areas and away from sparks and flames.

 

WARNING

Burn Hazards

Engine components can generate extreme heat. To prevent burns, DO NOT touch these areas while the engine is running or immediately after operations. Never operate the engine with heat shields or heat guards removed.

 

WARNING

Respiratory Hazards

ALWAYS wear approved respiratory protection when required.

PAGE 8 — STOW MS-70 MIXER — OPERATION MANUAL — REV. #3 (03/26/10)

Page 7 Page 9
Image 8
Page 7 Page 9
Contents Model MS-70 Page Heres HOW to GET Help Stow MS-70 PLASTER/MORTAR Mixer Table of Contents Direct TOLL-FREE access to our Parts Department Mixer Specifications Stow MS-70 PLASTER/MORTAR Mixer Dimensions DimensionsBurn Hazards Respiratory HazardsStow MS-70 Mixer Safety Message Alert Symbols Equipment DamageStow MS-70 PLASTER/MORTAR Mixer Rules for Safe Operation Read this manualMixer when in use Stand ClearTowing Safety Precautions Regularly Inspect Tow Bar toVehicle Connection Coupler OnlyReplacing Mixer Tow Bar Vehicle Connection Pintle and LoopStow MS-70 PLASTER/MORTAR Mixer Safety Chain Connection When TowingAlways Tow with Tow Bar to Mixer ConnectionMS-70 PLASTER/MORTAR Mixer Operation and Safety Decals Machine Safety DecalsEngine Maintenance Stow MS-70 PLASTER/MORTAR Mixer General InformationStow MS-70 PLASTER/MORTAR Mixer Basic Mixer Components Mixer ComponentsBurn Hazard Stow MS-70 PLASTER/MORTAR Mixer Basic Engine ComponentsFuel Hazard Electric Motor Connection Stow MS-70 PLASTER/MORTAR Mixer Electric MotorElectric Motor Electric MotorVoltage Switch Stow MS-70 Paddle Blade Adjustment Steel Drum Stow MS-70 PLASTER/MORTAR Mixer Inspection Before StartingInspection Engine Oil CheckStart/Stop Switch Controls Start/Stop SwitchesExplosive Fuel Belt CheckRespiratory Hazard Stow MS-70 PLASTER/MORTAR Mixer START-UP ProceduresGeneral Safety MS-70 PLASTER/MORTAR Mixer START-UP Procedures Engine ON/OFF SwitchDump Handle Safety Stow MS-70 PLASTER/MORTAR Mixer OPERATION/SHUT-DOWNStow MS-70 PLASTER/MORTAR Mixer Maintenance Engine Stow MS-70 PLASTER/MORTAR Mixer Maintenance Engine HazardBall Socket and Clamp Face Maintenance Drum Head SealsDrum Bearing Bracket Lubrication LubricatingStow MS-70 PLASTER/MORTAR Mixer Maintenance Mixer Main Gear and Drive Pinion AlignmentTires/Wheels/Lug Nuts DamagedWheelsTires Wear/Inflation Eyesight HazardLug Nut Torque Requirements Start all wheel lug nuts by handMixer Cleaning SuspensionKeep Hands Mixer StorageStow MS-70 PLASTER/MORTAR Mixer -TROUBLESHOOTING Engine Engine TroubleshootingWhite Stow MS-70 -TROUBLESHOOTING MIXER/ELECTRIC Motor Mixer TroubleshootingStow MS-70 Mixer Wiring Diagram Electric Motor Page Items Found In the Items Number Column BookItems Found In the Remarks Column Stow MS-70 Mixer Suggested Spare Parts Part numbers on thisNameplate and Decals DECAL, Safety Instructions DECAL, Warning Safety GrateSee Operation and Safety Decals DECAL, Towing InstructionsFrame Assy Safety Chain LOCK, PINCotter PIN Spring Locking PINPaddle Shaft Assy Paddle Shaft INSERT, Paddle ARMPaddle ARM, Engine END WASHER, Flat 1/2Stow MS-70 Mixer Steel Drum Assy Steel Drum AssyDrum Bearing Bracket CAP, DustSeparately FITTING, GreaseStow MS-70 Mixer Drum & Paddle Shaft Complete Assy Drum and Paddle Shaft Complete AssyPIN Cotter Bearing SealedCAP, Grease Fitting Axle Assy Dust CAP LUG NutsTire and RIM, Carlise Castle NUTEngine Assy Flat Washer 3/8 Pillow Block BearingRING, Retainer Pinion GearStow MS-70 Mixer Electric Motor Assy Shaft and Pinion Electric Motor 1.5 HPCabinet Assy SWITCH, PUSH-PULL Wire HarnessIncludes Items W Rubber ProtectorAIR Cleaner Assy ELEMENT, AIR CLEANER, Dual COVER, AIR CleanerGROMMET, AIR Cleaner COLLAR, AIR CleanerCamshaft Assy SPRING, Weight Return CamshaftROD Push ARM Valve RockerCarburetor Assy PLATE, Lever Setting Gasket SETValve SET, Float Float SETControl Assy ARM, Governor ROD, GovernorSPRING, Governor SPRING, Throttle ReturnCrankcase Cover Assy WEIGHT, Governor HOLDER, Governor WeightPIN, Governor Weight Type BalancerCrankshaft Assy Weight Balancer Cylinder Barrel Assy Switch ASSY., OIL Level SHAFT, Governor ARMBOLT, Drain Plug Ring 14MM AraiCylinder Head Assy GUIDE, VALVE, OS, Optional GUIDE, EX. VALVE, OS, OptionalCLIP, Valve Guide GASKET, Cylinder HeadFAN Cover Assy Switch ASSY., Engine Stop CLIP, Wire HarnessCLIP, Tube ShroudFlywheel Assy FAN, Cooling Flywheel CompNUT, Special 16MM KEY, Special WoodruffMuffler Assy Muffler PROTECTOR, MufflerPROTECTOR, EX. Pipe PIPE, EXFuel Tank Assy Rubber Supporter 107MM JOINT, Fuel TankTank COMP., Fuel *NH1*, Black GASKET, Fuel Filler CAPIgnition Coil Assy GROMMET, Wire WIRE, Stop Switch 370MMCoil ASSY., Ignition CAP ASSY., Noise SuppressorPiston Assy BOLT, Connecting ROD Ring SET, PISTON, STDRing SET, PISTON, 0.75, Optional PISTON, StandardRecoil Starter Assy PULLEY, Recoil Starter RATCHET, StarterSPRING, Friction SPRING, Starter ReturnGear Reduction Assy GEAR, Primary Drive 17T CountershaftSHAFT, P.T.O. H- Type Shim a OptionalLabel Assy Labels Assy EMBLEM, InternalMARK, CAUTION, External LABEL, CautionTerms and Conditions of Sale Stow Construction Equipment Page HERE’S HOW to GET Help
Top Page Image Contents