Vermont Casting VCS5037 Turning the Burners OFF, Flare-Ups, Match Lighting the Main Burners

Page 13

Operation

TURNING THE BURNERS OFF

1.Always turn the burner control knob(s) to the OFF position when cooking has been completed.

2.Promptly turn OFF the gas supply valve at the propane cylinder or at the main natural gas supply line.

3.Close the Hood of the Grill.

FLARE-UPS

“Flare-ups” sometimes occur when food drippings fall onto the hot sear plates or burners and ignite. Some flaring is normal and desirable, as it helps impart the unique flavors associated with grilled foods.

Controlling the intensity of the flare-ups is also desirable, however, in order to avoid burned or unevenly cooked foods and to prevent the possibility of an accidental fire.

WARNING: Always monitor the Grill carefully while cooking and turn the flame level down (LOW), or OFF, if flare-ups intensify. To prevent uncontrolled grease fires from erupting, never allow the grill to operate while unattended.

MATCH LIGHTING THE MAIN BURNERS:

1.a. Always open the Hood completely and always inspect the Grill and burners to confirm that all components are properly positioned before lighting the main burners.

b.Make sure the grease cup is empty and grease tray is clean.

c.Always visually inspect the gas supply line for fraying, cracking, or rodent damage before lighting the grill and, if necessary, install a replacement obtained from your dealer prior to lighting the grill.

WARNING: Never stand with your head directly over the Grill when preparing to light the main burners, to prevent possible bodily injury.

2.Always confirm that all of the burner control knobs are in the OFF position before opening the gas supply.

Fig. 10

3.Always turn on the propane gas supply valve at the tank (1 to 2 turns) or turn on the main natural gas supply valve.

4.Insert a lit match or a butane lighter into the match lighting hole located on the left hand side of the base, (see Fig. 10).

5.Turn the left Burner Control Knob to the HIGH position by pushing down on the knob and turning it counterclockwise.

6.Never store flammable or easily combustible objects (matches, butane lighters, cloths, etc.) in the pull out warming drawer (if equipped).

Page 8

Page 12 Page 14
Image 13
Page 12 Page 14
Contents USER’S Manual for Models Page Signal Words Safe Locations for USE of this Outdoor Grill Safe USE of Natural GAS Safe USE of LP Propane GASPrevention of Burns Electrical SafetyFuels Additional Warnings Safety Gas Hookup For Your Safety LP Propane GAS Supply ConnectionTo Disconnect Natural GAS Supply Connection To ConnectActivating the Igniter Electronic Ignition System Control Functions Propane Tank ValveLighting the Main Burners FLARE-UPS Turning the Burners OFFMatch Lighting the Main Burners Match Lighting the Rotisserie Burner To Start the Rotisserie BurnerRotisserie Setup if equipped Shutting the Burner OFF Lighting the Side Burner if equippedTroubleshooting Guide Troubleshooting Guide Unpack Carton and Verify Contents Assembly ProceduresInstall U-Clip Fasteners Parts Required Install the CastersAttach Shelves Parts Required Install the Side Shelf Supports Parts RequiredSecure Side Shelf to Grill Parts Required Secure Shelves Parts RequiredSecure Condiment Tray to Console Parts Required Attach Knobs Parts Required Attach Side Burner Lid S/B-Single Parts RequiredRemove the Packing Tape Attach the Handle to the Door Parts Required Install the Grease Cup and Grease Pan Parts RequiredAttach Stabilizer Bracket Parts Required Install the Battery Install the Internal Components Parts RequiredInstall the LP Cylinder LP Models Only Parts Required
Top Page Image Contents