Char-Broil 463250510 manual Regulator Tank Screw at rear of cart

Page 22

15

Place cooking grates onto the firebox as shown.

Place the Warming Rack onto the the firebox. Make sure insert the Warming Rack ends into the holes properly as shown.

Warming Rack

Cooking Grate

16

LP TANK IS SOLD SEPARATELY. Fill and leak check the tank before attaching to grill and regulator (see Use & Care section).

Once tank has been filled and leak checked, place cylinder into cut-out in bottom shelf. Make sure tank valve is facing front of grill.

Secure tank with tank screw under bottom shelf. Insert regulator through large hole in right side panel.

See Use & Care section of this manual to perform the "Burner Flame Check" and for important safety instructions before using.

LP Tank valve must face to front of cart once tank is attached. Failure to install cylinder correctly may allow gas hose to be damaged in operation, resulting in the risk of fire.

Tank Valve

 

Facing Front.

Regulator Tank Screw at rear of cart

 

LP Tank (not included)

Always keep LP tank in upright position during use, transport, and storage.

22

Page 21 Page 23
Image 22
Page 21 Page 23
Contents Estimated assembly time 30 minutes Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Main Burner Ignitor LightingSideburner Match Lighting General Grill CleaningSideburner Ignitor Lighting Burner Flame CheckTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill BurnerLimited Warranty Items Manufacturer will not PAY forParts List Key Qty DescriptionParts Diagram Assembly RearGrill head Regulator hose Upper back panel 5mm Flat Washer Left On fascia to attach bezel Sideburner Sideburner drip pan Burner tube Heat shield Right door Left door Regulator Tank Screw at rear of cart Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Integrated Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA
Top Page Image Contents