Char-Broil 463250510 manual Assembly, Rear

Page 13

ASSEMBLY

1

Attach the two locking casters at the rear of the bottom shelf and the two fixed casters at the front. Use the provided caster wrench to fully tighten casters.

Fixed caster

Locking caster

Front

Bottom shelf

Rear

2

Attach side panels to bottom shelf using three 1/4-20x1/2”screws, 7mm lock washers, and 7mm flat washers per panel.

IMPORTANT: Panel with large hole must be on left side of bottom shelf.

1/4-20x1/2” screw

7mm lock washer

7mm flat washer

Left side panel

Make sure side panels are pushed as far to the rear of bottom shelf as possible before fully tightening screws.

Right side panel (with large hole)

Door magnet

13

Image 13

Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Main Burner Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjurySideburner Ignitor Lighting General Grill CleaningSideburner Match Lighting Burner Flame CheckStoring Your Grill Cleaning the Burner AssemblyTurn gas OFF at control knobs and LP cylinder BurnerItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram Rear AssemblyGrill head Regulator hose Upper back panel 5mm Flat Washer Left On fascia to attach bezel Sideburner Sideburner drip pan Burner tube Heat shield Right door Left door Regulator Tank Screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Integrated Electronic IgnitionPage Warranty Registration Department Box Columbus, GA