Char-Broil 463269011 manual 7mm lock, 7mm flat Washer

Page 15

4

Insert front brace under control panel and between cart side panels.

Secure using two 1/4-20x1½”screws, 7mm lock washers, and 7mm flat washers on each side.

NOTE: MAKE SURE THAT THE FRONT BRACE IS MOUNTED IN THE MOST DOWNWARD POSITION WHEN ASSEMBLED TO CART.

Control panel

		1/4-20x1½”
		screw
		7mm lock
Front brace	7mm flat	washer
	7mm flat
	washer

		Attach left side fascia to left side shelf using two #10x3/8” screws, 5mm lock washers and 5mm flat washers.
	5
	5	Only left side shelf shown for assembly, install right side shelf with fascia in the same way.

5mm flat washer

5mm lock washer #10x3/8” screw

Left side shelf

Left side fascia

15

Image 15

Contents Estimated assembly time 30-40 minutes Date PurchasedConversion to Natural Gas requires Conversion Kit #5729581 This Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsUSE and Care LP Liquefied Petroleum GasLP Cylinder Filling For your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF Main Burner Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjuryBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingStoring Your Grill Cleaning the Burner AssemblyItems Manufacturer will not PAY for Limited WarrantyNot Pictured Key Qty Description Parts ListParts Diagram 20x1/2 screws, 7mm lock washers, AssemblyMake sure the regulator hose is hanging inside the cart 7mm flat Washer 7mm lockWasher and 1/4 nut each side, shown A/B Remove Screw Washers Front Brace Flat washers on each sideWire Pin Flame tamersCooking grate Cylinder screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA