Char-Broil 463269011 manual Flat washers on each side, Front Brace

Page 18

	8	On back of grill, place upper back panel between side panels, using two 1/4-20x1½”screws, 7mm lock washers and 7mm
	8	flat washers on each side.
		flat washers on each side.

1/4-20x1½” screw

	7mm flat	7mm lock
	washer	7mm lock
	washer	washer

	9	Insert left and right grease tray rails into slots beneath grease tray opening in upper back panel, shown A.
	9	Attach right and left rails under front brace with two #8x3/8” self-tapping screws, shown B.

A

B

Grease tray opening

Front Brace

Left rail

Right rail

	#8x3/8”	Right rail
	self-tapping screw	Right rail
	self-tapping screw
		Left rail

18

Image 18

Contents Estimated assembly time 30-40 minutes Date PurchasedConversion to Natural Gas requires Conversion Kit #5729581 Table of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionUSE and Care LP Liquefied Petroleum GasLP Cylinder Filling For your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Main Burner Ignitor LightingSideburner Match Lighting General Grill CleaningSideburner Ignitor Lighting Burner Flame CheckCleaning the Burner Assembly Storing Your GrillLimited Warranty Items Manufacturer will not PAY forParts List Not Pictured Key Qty DescriptionParts Diagram Assembly 20x1/2 screws, 7mm lock washers,Make sure the regulator hose is hanging inside the cart 7mm lock 7mm flat WasherWasher and 1/4 nut each side, shown A/B Remove Screw Washers Flat washers on each side Front BraceWire Flame tamers PinCooking grate Cylinder screw at rear of cart Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA