Char-Broil 463269011 manual Remove Screw Washers

Page 17

7	Remove the two screws and washers which were attached on left side of firebox front, shown A.
	Insert flange on left side shelf into side shelf brackets on side of firebox, shown B .

Attach left side shelf using two 1/4-20X1/2”small head screws, 7mm flat washers, 7mm lock washers and 1/4” nuts, shown C.

Attach front of shelf and fascia using one #8x3/8” self-tapping screw and large flat washer, shown D .

Attach left side shelf front using the two screws and washers which were removed from left side of fire box, shown D.

Only left side shelf shown for assembly, repeat above steps to install right side shelf.

B

			Left side shelf
			Left side shelf
	A		Side shelf bracket

remove

D

Screw

Washers

		#8x3/8” self-tapping
	C	#8x3/8” self-tapping
	C	screw
		screw

Large flat washer

*Screws and washers removed from left side of firebox front.

1/4”nut	1/4-20x1/2” small
	head screw

7mm lock

washer 7mm flat washer

17

Image 17

Contents Conversion to Natural Gas requires Conversion Kit #5729581 Estimated assembly time 30-40 minutesDate Purchased This Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsLP Cylinder Filling USE and CareLP Liquefied Petroleum Gas LP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Turn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator Main Burner Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjurySideburner Ignitor Lighting General Grill CleaningSideburner Match Lighting Burner Flame CheckStoring Your Grill Cleaning the Burner AssemblyItems Manufacturer will not PAY for Limited WarrantyNot Pictured Key Qty Description Parts ListParts Diagram 20x1/2 screws, 7mm lock washers, AssemblyMake sure the regulator hose is hanging inside the cart 7mm flat Washer 7mm lockWasher and 1/4 nut each side, shown A/B Remove Screw Washers Front Brace Flat washers on each sideWire Pin Flame tamersCooking grate Cylinder screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA