Char-Broil 463440109 manual Right Side Shelf, Qty 7X15 Fiber Washer

Page 20

6

Hook side wall of shelf over support brackets on side of firebox (A).

Inside firebox insert 7x15 fiber washers and 1/4"-20x1/2" machine screws as shown (B).

Attach shelf with flange nuts on each side. (C).

B

A

Bracket

Right Side Shelf

C

Qty: 4	Qty: 4
1/4"-20x1/2"	1/4"-20
Machine Screw	Flange Nut

Qty: 4

7X15 Fiber Washer

Attach fascia to firebox with #8-32x3/8" sheet metal screws.

7

Qty:2

#8-32x3/8”Sheet Metal Screw

20

Image 20

Contents Estimated assembly time 45 minutes Date PurchasedINSTALLER/ASSEMBLER Installation Safety Precautions California PropositionLP Liquefied Petroleum Gas LP Cylinder FillingUL listed Overfill Protection Only LP cylinders equipped with this type of valveConnecting Regulator to the LP Cylinder For your safetyUseDo not household cleaning agents. Damage to gas LP Cylinder ExchangeTurn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator For Safe Use of Your Grill and to Avoid Serious Injury Ignitor LightingSDo not lean over grill while lighting Open lid during lightingGeneral Grill Cleaning Sideburner Ignitor LightingSideburner Match Lighting Burner Flame CheckCleaning the Burner Assembly Storing Your GrillTurn gas off at control knobs and LP cylinder Very Important Burner tubes must reengage valveTemperature First Time UseLava Rock / Briquettes RegulatorFood Safety Direct CookingIndirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures Why Clean? General CleaningRoutine Care Storing Your GrillLimited Warranty Key Qty Description Not PicturedParts Diagram Bottom Shelf Axle Hole LP tank holeFront Panel WheelHitch Pin Axle WasherGrill Head Right Side Shelf Qty 7X15 Fiber WasherSideburner Shelf Sideburner Swing Away Leg Wire Cooking Grate Heat TentGrease Cup Clip LP Tank Tank ThumbscrewTroubleshooting Emergencies Possible Cause Prevention/SolutionElectronic Ignition Troubleshooting Electronic Ignition SectionPage Page Page Regtemp REV00