Char-Broil 463440109 manual Grease Cup Clip, LP Tank Tank Thumbscrew

Page 24

Hang grease cup clip from bottom of firebox and place grease cup into grease clip.

13

Grease Cup Clip

Grease Cup

CAUTION

Failure to install grease cup clip and cup will cause hot grease to drip from bottom of grill with risk of fire or property damage.

14	LP tank is sold separately. Use only with an OPD (over-fill protection device) equipped LP tank. Fill and leak check before
	attaching to grill and regulator.
	Place LP tank into hole in bottom shelf with tank collar opening facing to side as shown. Finger tighten tank thumbscrew

to hold LP tank securely in place.

See Use and Care section to correctly Leak Test and perform the Burner Flame Check

CAUTION

•Failure to install tank correctly may allow gas hose to be damaged in operation, resulting in the risk of fire.

LP Tank

Tank Thumbscrew

24

Image 24

Contents Estimated assembly time 45 minutes Date PurchasedINSTALLER/ASSEMBLER Installation Safety Precautions California PropositionLP Liquefied Petroleum Gas LP Cylinder FillingUL listed Overfill Protection Only LP cylinders equipped with this type of valveConnecting Regulator to the LP Cylinder For your safetyUseDo not household cleaning agents. Damage to gas LP Cylinder ExchangeLeak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Ignitor LightingSDo not lean over grill while lighting Open lid during lightingGeneral Grill Cleaning Sideburner Ignitor LightingSideburner Match Lighting Burner Flame CheckCleaning the Burner Assembly Storing Your GrillTurn gas off at control knobs and LP cylinder Very Important Burner tubes must reengage valveTemperature First Time UseLava Rock / Briquettes RegulatorFood Safety Direct CookingIndirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures Why Clean? General CleaningRoutine Care Storing Your GrillLimited Warranty Key Qty Description Not PicturedParts Diagram Bottom Shelf Axle Hole LP tank holeFront Panel WheelHitch Pin Axle WasherGrill Head Right Side Shelf Qty 7X15 Fiber WasherSideburner Shelf Sideburner Swing Away Leg Wire Cooking Grate Heat TentGrease Cup Clip LP Tank Tank ThumbscrewTroubleshooting Emergencies Possible Cause Prevention/SolutionElectronic Ignition Troubleshooting Electronic Ignition SectionPage Page Page Regtemp REV00