Char-Broil 463210510 manual Sideburner Valve

Page 22

11	Remove two #8-32x5/16” screws from sideburner valve bracket,set aside until step 12.
	Repeat step 8(A)on left side shelf. Place left side shelf to the side of firebox(A).
	Tighten the pre-installed screws to the left side shelf(B). Make sure valve is inside sideburner tube.
	Attach left side shelf to the firebox with 1/4-20x1/2" screws on the upper	holes. Attach left	fasica	to control	panel
	with #10-24x1/2" screws . Attach sideburner ignitor wire to the electronic	ignition module	through	the hole	of the
	left plate of control panel(C).

Attach left towel bar to the rear of left side shelf with #10-24x1/2" screws and #10-24 hex nuts.

Attach left towel bar to the front of left fascia with #8-32x5/16” screw and #8-32 hex nut(D).

Left Side Shelf

Qty: 2	Qty: 7	Qty: 1
1/4-20x1/2"	#10-24x1/2"	#8-32x5/16”	A
Machine Screw	Machine Screw	Machine Screw	A

Qty: 5	Qty: 1
#10-24 Hex Nut	#8-32 Hex Nut

B	Sideburner Valve

Sideburner Tube

Left Fascia

Left Towel Bar

Sideburner Ignitor Wire

Image 22

Contents Estimated assembly time 35-40 minutes Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionLava Rock / Briquettes TemperatureFirst Time Use Pre-Heating Your GrillIndirect Cooking Food SafetyDirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures Routine Care Why Clean?General Cleaning Storing Your GrillLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling LP Cylinder Leak Test For your safetyDo not use household cleaning agents. Damage to gas Nipple has to be centered into the LP cylinder valveConnection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF SDo not lean over grill while lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting Open lid during lightingSideburner Match Lighting General Grill CleaningSideburner Ignitor Lighting Burner Flame CheckTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveLimited Warranty Disclaimer of Implied Warranties and Limitation of RemediesKey Qty Description Parts ListNot Pictured Parts Diagram Assembly Upper Front panelQty Tank Retainer ,Wire Form Hitch Pin Qty #10-24x1/2 Machine ScrewQty 20x1/2 Machine Screw Page Sideburner Valve Ten t Page Hose Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionPage Page Warranty Registration Department Box Columbus, GA