Char-Broil 463210011 manual Back of main control panel

Page 17

8

Insert flange on right side shelf into side shelf brackets on side of firebox, shown A.

Attach right side shelf using three 1/4”-20x3/4”screws, 7mm flat washers, 7mm lock washers and 1/4” nuts, shown B. Attach rear of shelf using one 1/4-20x1½”screw, 7mm lock washer, and 7mm flat washer in lower hole, shown C. Attach front of shelf and fascia using one #8x3/8” self-tapping screw, shown D.

Attach front of shelf and fascia using one 1/4”-20x3/4”screw, 7mm flat washer, 7mm lock washer and 1/4” nut, shown D/E.

Only right side shelf shown for assembly, repeat above steps to install left side shelf.

A

Right side shelf

		C
		1/4-20x1½”
	7mm flat	screw
	7mm flat	7mm lock
	washer	7mm lock
	washer	washer

Bracket

D

#8x3/8” self-tapping screw

1/4”nut

7mm lock washer

7mm flat washer

E Back of main control panel

Main control panel

Igniter Switch

1/4-20x3/4”

screw Fascia, right side shelf

B

1/4-20x3/4”

screw

7mm flat washer

7mm lock

1/4”nut washer

17

Image 17

Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsLP Cylinder Filling USE and CareLP Liquefied Petroleum Gas LP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Turn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjurySDo not lean over grill while lighting Open lid during lightingSideburner Ignitor Lighting General Grill CleaningSideburner Match Lighting Burner Flame CheckStoring Your Grill Cleaning the Burner AssemblyVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram Front AssemblyUpper back panel Temperature gauge stem Bracket Back of main control panel Grease tray opening Left rail Right rail Wire Flame tamers Grease tray Cylinder screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA