Char-Broil 463247512 manual Grill head Regulator hose

Page 14

3

Place lower back panel between side panels at rear of bottom shelf. Make sure the slots are positioned as shown A. Secure lower back panel to side panels using two 1/4-20x1/2”screws, 7mm lock washers, and 7mm flat washers on each side.

7mm lock washer	1/4-20x1/2” screw

Lower back panel

7mm flat washer

A

Vertical flange

The vertical flange should be on right side when the lower back panel is properly installed.

4

This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart, aligning slots at bottom of grill head with posts on cart side panels. Make sure the regulator hose is hanging outside the cart. Grill head must face open side of cart.

Grill head

Regulator hose

14

Image 14

Contents Product Guide Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionLP Cylinder Filling USE and CareLP Liquefied Petroleum Gas UL listed Overfill ProtectionLP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Turn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator SDo not lean over grill while lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting Open lid during lightingSideburner Match Lighting General Grill CleaningSideburner Ignitor Lighting Burner Flame CheckVery Important Burner tubes must reengage valve Cleaning the Burner AssemblyStoring Your Grill Turn gas OFF at control knobs and LP cylinderLimited Warranty Items Manufacturer will not PAY for Parts List Key Qty DescriptionParts Diagram Assembly Grill head Regulator hose Rear of Shelf Back of main control panel Now you may fully tighten lower screws on upper back panelFront of Shelf Holes on fascia to Attach bezel Holes on fascia toAttach valve bracket Sideburner lid Sideburner griddle Sideburner grate Front brace AA battery Cap WireFlame tamer Pin Slide into slots Important safety instructions before using Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionWarranty Registration Department Box Columbus, GA