Char-Broil 463247512 manual Rear of Shelf

Page 15

5

On back of grill, place upper back panel between side panels and above lower back panel.

Secure upper back panel, in lower holes, using one 1/4-20x1½”screw, 7mm lock washer, and 7mm flat washer on each side.

Do not fully tighten screws until side shelf installation is complete in later steps.

1/4-20x1½” 7mm lock 7mm flat

screw washer washer

Upper back panel

6

Insert flange on right side shelf into side shelf brackets on side of firebox, shown A.

Attach rear of shelf using one 1/4-20x3/4”screw, 7mm lock washer, 7mm flat washer and 1/4”nut in upper hole; using one 1/4-20x1½”screw, 7mm lock washer and 7mm flat washer in lower hole, shown B/C.

Attach front of shelf and fascia using two 1/4-20x3/4”screws, 7mm flat washers, 7mm lock washers and1/4”nuts, and one #8x3/8” self-tapping screw with large washer, shown C/D/E.

A

BRear of Shelf

1/4-20x3/4” screw

1/4-20x1½” screw

7mm flat 7mm lock

washer washer

	7mm lock	7mm flat
	washer	washer
	1/4”nut	washer
	1/4”nut

1/4”nut

C

7mm lock washer

7mm flat washer

DBack of main control panel

#8x3/8” tapping screw

large flat washer

E

1/4-20x3/4” screw

1/4-20x3/4” screw

Note: Insert this screw from the back of main control panel.

7mm lock washer

1/4”nut

7mm flat washer

15

Image 15

Contents Date Purchased Product GuideThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsUL listed Overfill Protection USE and CareLP Liquefied Petroleum Gas LP Cylinder FillingFor your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting SDo not lean over grill while lightingBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram Assembly Grill head Regulator hose Rear of Shelf Now you may fully tighten lower screws on upper back panel Front of ShelfBack of main control panel Holes on fascia to Attach valve bracketHoles on fascia to Attach bezel Sideburner lid Sideburner griddle Sideburner grate Front brace Wire AA battery CapFlame tamer Pin Slide into slots Important safety instructions before using Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionWarranty Registration Department Box Columbus, GA