Char-Broil 463247512 Now you may fully tighten lower screws on upper back panel, Front of Shelf

Page 16

7

Insert tabs on left sideburner shelf assembly into rectangular slots in side of firebox, shown A.

Attach rear of shelf using one 1/4-20x3/4”screw, 7mm flat washer, 7mm lock washer and 1/4”nut in upper hole; and using 1/4-20x1½”screw, 7mm lock washer, 7mm flat washer in lower hole, shown B/C.

Attach front of shelf and fascia using two 1/4-20x3/4”screws, 7mm flat washers, 7mm lock washers and 1/4”nuts, and one #8x3/8” self-tapping screw with large washer, shown C/D/E.

Now you may fully tighten lower screws on upper back panel.

B

1/4-20x3/4” screw

1/4-20x1½” screw

7mm lock washer

7mm flat washer

C

7mm flat washer

7mm lock washer

1/4”nut

A

7mm flat washer

7mm lock washer

1/4”nut



Front of Shelf	D
Front of Shelf

1/4-20x3/4” screw

#8x3/8” tapping screw

large flat washer

1/4”nut

Back of main control panel

E

Control panel

1/4-20x3/4” screw

Note:

Insert this screw from the back of main control panel

7mm lock washer

7mm flat washer

16

Image 16

Contents Product Guide Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionUSE and Care LP Liquefied Petroleum GasLP Cylinder Filling UL listed Overfill ProtectionUseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Ignitor LightingSDo not lean over grill while lighting Open lid during lightingGeneral Grill Cleaning Sideburner Ignitor LightingSideburner Match Lighting Burner Flame CheckCleaning the Burner Assembly Storing Your GrillVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderLimited Warranty Items Manufacturer will not PAY forParts List Key Qty DescriptionParts Diagram Assembly Grill head Regulator hose Rear of Shelf Front of Shelf Now you may fully tighten lower screws on upper back panelBack of main control panel Attach valve bracket Holes on fascia toHoles on fascia to Attach bezel Sideburner lid Sideburner griddle Sideburner grate Front brace AA battery Cap WireFlame tamer Pin Slide into slots Important safety instructions before using Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionWarranty Registration Department Box Columbus, GA