Weber 5000 Series owner manual Manual Lighting

Page 31

Manual Lighting

DANGER

Failure to open lid while igniting the barbecue, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame- up which can cause serious bodily injury or death.

1)Open the lid. Figure 2.

2)Check that fuel scale reads more than “E”. Note - E = empty; F = full.

3)Make sure all burner control knobs are turned OFF. (Push each knob down and turn clockwise.)

WARNING: The burner control knobs must be in the OFF position before turning on the LP tank valve. If they are not in the OFF position, when you turn on the LP tank valve, the excess flow control will activate, limiting the flow of gas from the LP tank. If this should occur, turn OFF the LP tank valve and burner control knobs and start over.

DANGER

When the excess flow control is activated, a small amount of gas is still flowing to the burners. After turning OFF the tank and burner control knobs, wait at least 5 minutes for the gas to clear before attempting to light the barbecue. Failure to do so may result in an explosive flame- up which can cause serious bodily injury or death.

1

Manual Lighting

3

9

4

6

8 5 7

2

Figure 2

4)Turn the tank on by turning the tank valve counterclockwise.

5)Push Front burner control knob down and turn to START/HI.

WARNING: Do not lean over open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the barbecue.

6)Strike a match and put the flame into the matchlight hole in the front of the cooking box.

7)Push down and hold the FlameCheck button down.

Note - Gas is supplied to the burner only when the FlameCheck button is depressed.

8)Check that the burner is lit by looking through the matchlight hole on the front of the cooking box.

If the burner is lit, continue to hold the FlameCheck button down for about 8 seconds. When the button is released the burner will stay lit.

WARNING: If the burner does not light, turn the Front burner control knob to OFF and wait 5 minutes to let the gas clear before you try again or try to light with a match.

9)After the FRONT burner is lit you can turn on the other burners.

Note - The FRONT burner must be on at all times when operating the other burners. The FlameCheck Safety System monitors the Front burner. For your safety, the FlameCheck valve will shut off the gas to the burners if the front burner should inadvertently go out during cooking.

To Extinguish

Turn gas supply OFF at the source, then push down and turn each burner control knob clockwise to OFF.

31

Image 31
Contents Genesis 5000 Series LP GAS Units only Warranty Patents and Trademarks Contents Operating area For Installation in CanadaGeneral Instructions StorageCheck package contents AssemblyStep Page Page Check contents of hardware packs Assemble frame Assemble wheelsComplete frame assembly Continue frame assemblyInstall left end panel Check the frame assemblyInsert casters Install side burner locks Install the three back panelsAdd cooking box Install manifold bracket Install side burnerInstall right end panel Install tank panel assemblyInstall igniter Install bottom accessory traysAdd fuel scale Check that all burner valves are off Install left hand swing tableInstall right hand swing table Hinge rod View from rear of barbecue Fill LP tank Set LP fuel scaleConnect LP tank Check for gas leaks Insert Flavorizer Bars Steam-N-Chips Smoker Install the bottom tray Install cooking gratesInstall the lid Secure side burner Install glass doorsComplete accessory installation To Extinguish LightingManual Lighting Lighting the side burner Side burner will only operate when the Front burner is litStorage and/or Nonuse Periodic CleaningCooking Storage and/or NonuseTo use the Steam-N-Chips Smoker Using the Steam-N-Chips SmokerRemoval of the LP tank Refilling the LP tankEngaged Liquid Propane LP Tanks Safe handling tips for LP GasInspection and Cleaning of the Weber Spider Stopper Guards Annual MaintenanceMain Burner Flame Pattern General MaintenanceMain Burner Cleaning Procedure Weber Spider Stopper GuardsView from behind cooking box Wing nuts Crossover Ignition System Operations FlameCheck Safety System Resembles paint peeling When burner is on HIGH. Flames do not runBurner does not light, or flame is low in High position Burner flame pattern is erratic. Flame is lowFlame is low in High position Side Burner TroubleshootingSide Burner Maintenance Problem Check Cure Side burner does not lightPage 19-20 22-24 Parts List Final Word Thanks

5000 Series specifications

The Weber 5000 Series is a flagship line of outdoor grills that has garnered attention among barbecue enthusiasts and culinary professionals alike. Known for their superior engineering and innovative technologies, these grills are designed to deliver an exceptional grilling experience combined with robust functionality.

One standout feature of the Weber 5000 Series is its exceptional heat retention and distribution system. With a powerful gas cooking system, users can expect consistent temperatures across the grilling surface, ensuring that food is cooked evenly. This is achieved through high-performance burners that provide efficient heat output while minimizing fuel consumption, making it an eco-friendly choice as well.

The series is equipped with Weber's signature Flavorizer bars, which are designed to vaporize drippings and infuse the food with a rich, smoky flavor. These bars are strategically placed above the burners to catch and recycle fat and juices, allowing for a flavor-enhancing experience that is beloved by grillers. The series also features premium cooking grates made from stainless steel, which are not only durable but also provide great heat retention for the perfect sear.

Another highlight of the Weber 5000 Series is its integrated technology, including the iGrill app connectivity. This feature allows users to monitor their cooking progress via a smartphone, providing alerts when the food reaches the desired temperature. This smart technology takes the guesswork out of grilling, making it easier for anyone to achieve restaurant-quality results.

In terms of design, the Weber 5000 Series boasts a sleek and modern aesthetic, with options for various finishes that will complement any outdoor space. It includes a spacious cooking area, making it viable for both intimate family dinners and larger gatherings. Additional features such as side burners and built-in storage enhance the cooking experience and provide added convenience for outdoor meal preparation.

The Weber 5000 Series is built to last, constructed with weather-resistant materials to withstand the elements. This durability ensures that users can enjoy years of dependable grilling, making it a worthwhile investment for outdoor cooking enthusiasts.

Overall, the Weber 5000 Series stands out in the market for its combination of high-performance features, innovative technology, and thoughtful design. It is an excellent choice for those who appreciate quality grilling and are looking to elevate their outdoor cooking experience.