Weber 5000 Series owner manual Hinge rod View from rear of barbecue

Page 21

Insert one end of the hinge rod into the hole in the frame. Figure 28 (a).

Insert the other end into the hole in the swing table end bracket. Figure 28 (b). Hold the end bracket at an angle so the lower tab is inside the frame tube. Push the bracket into the frame. Check to see that the lower tab of the bracket is hooked in the slot in the frame. Figure 28 (c).

To fully seat the bracket, you may have to tap it lightly with a hammer.

WARNING: If swing table end bracket is in any way cracked or damaged, do not use swing table. Call our Customer Service Center to order a new part.

WARNING: The load limit for the swing table is 30 pounds.

(a)

(b)

Hinge rod

View from rear of barbecue

(c)

Position slide bar assembly on the outside of the wheel frame. Put a nylon washer on each 1 3/4 inch screw, insert screws through frame and slide bar assembly and add nylon washers and hex nuts. Tighten nuts using a screwdriver and pliers. Figure 29.

Notch

F

Slide bar

 

F

View from front of barbecue

Wheel frame

Figure 29

To lower table: Pull support rod up to disengage slide lock and lower table. To raise table, lift table up and engage slide in locked position. Figure 30.

Support rod

Figure 28

Slide

Slot in frame (view from below)

Unlocked position

Locked position

Figure 30

21

Page 20 Page 22
Image 21
Page 20 Page 22
Contents Genesis 5000 Series LP GAS Units only Warranty Patents and Trademarks Contents General Instructions For Installation in CanadaStorage Operating areaAssembly Check package contentsStep Page Page Check contents of hardware packs Assemble frame Assemble wheelsComplete frame assembly Continue frame assemblyCheck the frame assembly Install left end panelInsert casters Install side burner locks Install the three back panelsAdd cooking box Install manifold bracket Install side burnerInstall right end panel Install tank panel assemblyInstall bottom accessory trays Install igniterAdd fuel scale Check that all burner valves are off Install left hand swing tableInstall right hand swing table Hinge rod View from rear of barbecue Fill LP tank Set LP fuel scaleConnect LP tank Check for gas leaks Insert Flavorizer Bars Steam-N-Chips Smoker Install the bottom tray Install cooking gratesInstall the lid Secure side burner Install glass doorsComplete accessory installation To Extinguish LightingManual Lighting Lighting the side burner Side burner will only operate when the Front burner is litCooking Periodic CleaningStorage and/or Nonuse Storage and/or NonuseTo use the Steam-N-Chips Smoker Using the Steam-N-Chips SmokerRemoval of the LP tank Refilling the LP tankEngaged Liquid Propane LP Tanks Safe handling tips for LP GasInspection and Cleaning of the Weber Spider Stopper Guards Annual MaintenanceMain Burner Cleaning Procedure General MaintenanceWeber Spider Stopper Guards Main Burner Flame PatternView from behind cooking box Wing nuts Crossover Ignition System Operations FlameCheck Safety System Burner does not light, or flame is low in High position When burner is on HIGH. Flames do not runBurner flame pattern is erratic. Flame is low Resembles paint peelingSide Burner Maintenance Side Burner TroubleshootingProblem Check Cure Side burner does not light Flame is low in High positionPage 19-20 22-24 Parts List Final Word Thanks

5000 Series specifications

The Weber 5000 Series is a flagship line of outdoor grills that has garnered attention among barbecue enthusiasts and culinary professionals alike. Known for their superior engineering and innovative technologies, these grills are designed to deliver an exceptional grilling experience combined with robust functionality.

One standout feature of the Weber 5000 Series is its exceptional heat retention and distribution system. With a powerful gas cooking system, users can expect consistent temperatures across the grilling surface, ensuring that food is cooked evenly. This is achieved through high-performance burners that provide efficient heat output while minimizing fuel consumption, making it an eco-friendly choice as well.

The series is equipped with Weber's signature Flavorizer bars, which are designed to vaporize drippings and infuse the food with a rich, smoky flavor. These bars are strategically placed above the burners to catch and recycle fat and juices, allowing for a flavor-enhancing experience that is beloved by grillers. The series also features premium cooking grates made from stainless steel, which are not only durable but also provide great heat retention for the perfect sear.

Another highlight of the Weber 5000 Series is its integrated technology, including the iGrill app connectivity. This feature allows users to monitor their cooking progress via a smartphone, providing alerts when the food reaches the desired temperature. This smart technology takes the guesswork out of grilling, making it easier for anyone to achieve restaurant-quality results.

In terms of design, the Weber 5000 Series boasts a sleek and modern aesthetic, with options for various finishes that will complement any outdoor space. It includes a spacious cooking area, making it viable for both intimate family dinners and larger gatherings. Additional features such as side burners and built-in storage enhance the cooking experience and provide added convenience for outdoor meal preparation.

The Weber 5000 Series is built to last, constructed with weather-resistant materials to withstand the elements. This durability ensures that users can enjoy years of dependable grilling, making it a worthwhile investment for outdoor cooking enthusiasts.

Overall, the Weber 5000 Series stands out in the market for its combination of high-performance features, innovative technology, and thoughtful design. It is an excellent choice for those who appreciate quality grilling and are looking to elevate their outdoor cooking experience.
Top Page Image Contents