Golden Technologies GL140, GL110 Reinstall the Drivetrain, Drivetrain Alignment, Raise the Tiller

Page 28

LiteRider™ Owner’s Manual

Rev.A_122810

VIII. ASSEMBLY

Reinstall the Drivetrain

1.Line up the two yellow tabs on the frame, with the two grooves on the drivetrain, one on each side of the scooter. See figure 20.

WATCH FINGER PLACEMENT! BE CAREFUL NOT TO PINCH YOUR FINGERS!

2.Lower the frame onto the drivetrain until the drivetrain release lever engages. You should hear an audible click.

Figure 20. Drivetrain Alignment

Figure 21. Battery Pack Installation

Install the Battery Pack

3. Gently lower the battery pack onto the frame. See figure 21.

Raise the Tiller

4.Loosen the tiller adjustment knob and raise the tiller. See #1 on figure 22.

5.Tighten the tiller adjustment knob at the desired position.

– MAKE SURE YOU TIGHTEN YOUR TILLER KNOB TO BE SURE IT IS SECURED IN THE DESIRED POSITION!

Tiller lock in unlocked position.

Figure 22. Tiller Raised and Unlocked

Image 28

Contents Y O U R L I F E I N M O T I O N Owner’s ManualMODELS GL110/GL140 LiteRider Owner’s Manual Rev.A122810LiteRider Models GL110/GL140 Standard Packing List 1 Owner’s Manual CONTENTS I. INTRODUCTION FEATURES AND BENEFITS Figure 1. LiteRider Features 4-wheelACCESSORIES FOR THE LITERIDER SCOOTER II. SAFETY MAXIMUM WEIGHTBEFORE GETTING ON YOUR LITERIDER GETTING ON YOUR LITERIDERDRIVING ON INCLINES LiteRider maximum recommend incline isFigure 2. Going Up an Incline DRIVING DOWN A DECLINEProcedure 1 - Under Power Procedure 2 - Emergency No Power3. Dismount your LiteRider 2. Dismount your LiteRiderRULES FOR USE AND OTHER SAFETY CONSIDERATIONS MEDICATIONRULES FOR USE AND OTHER SAFETY CONSIDERATIONS - continued III. EMI/RFI EMI/RFI AND YOUR LITERIDERFigure 4. Your Golden LiteRider 3-wheel IV. YOUR GOLDEN LiteRiderFOR YOUR RECORDS Specification Weight of Unit assembledGL-110 TiresSpecifications WarrantyStandard Seat Optional SeatSpeed Adjustment Dial Key SwitchV. OPERATION CONTROL PANELDC Battery Voltage Meter DELTA TILLER ADJUSTMENTDelta Tiller Throttle Control Lever To drive forward use either of the followingArmrest Width Adjustment Seat Height AdjustmentFigure 6. Armrest Width Adjustment Figure 7. Flip-up/Angle AdjustmentFigure 9. Freewheel Mode Brake Disengaged FREEWHEEL MODEFigure 10. Drive Mode Brake Engaged Figure 11. Key Switch Off Figure 12. Key Switch OnVI. RIDING YOUR LiteRider MOUNTINGBASIC DRIVING SteeringSteering in a Tight Spot Steering in ReverseRamps When proceeding up any ramp, curb, or incline CONTROL THROUGH TIGHT SPOTSIf you must stop your LiteRider while driving up a ramp Driving down a rampVII. DISASSEMBLY DISASSEMBLYFigure 14. Removing the Battery Pack Remove the Battery PackFigure 16. Lowered Tiller Separate the Drivetrain from the FrameFigure 17. Releasing the Drivetrain Figure 18. Lifting the FrameVIII. ASSEMBLY Figure 19. LiteRider Components 4-wheelReinstall the Drivetrain WATCH FINGER PLACEMENT! BE CAREFUL NOT TO PINCH YOUR FINGERSFigure 21. Battery Pack Installation Install the Battery PackInstall the Under-the-Seat and Tiller Baskets Install the SeatFigure 23. Installing the Seat Unlock the TillerFigure 24. LiteRider Models GL110/140 IX. TRANSPORTING YOUR LITERIDERTo Transport Your LiteRider X. CARE AND MAINTENANCE ROUTINE MAINTENANCECLEANING YOUR LiteRider Tires BodyBattery Maintenance BATTERIES AND CHARGINGTo Charge the Batteries Figure 25. Charging BatteriesIF YOUR LiteRider DOES NOT OPERATE Figure 27. Main Circuit BreakerPossible causes for the main circuit breaker to trip RemedyDIAGNOSTICS Resetting the Main Circuit BreakerBeep Codes 1 Beep 2 Beeps5 Beeps 4 Beeps6 Beeps 8 Beeps 7 Beeps9 Beeps XI. WARRANTY Consumer Limited WarrantyScooters Effective June Lifetime Limited WarrantyGolden Technologies’ Consumer Limited Warranty Scooters continuedOne-Year Limited Warranty Warranty ExclusionsXII. WARRANTY/REGISTRATION FORM Golden Technologies Product Registration FormOWNER INFORMATION PRODUCT INFORMATIONRev.A122810 Fold Here First Place Stamp Here Golden Technologies 401 Bridge St Old Forge, PA Fold Here SecondLiteRider Owner’s Manual Y O U R L I F E I N M O T I O N Models GL110/GL140LiteRiderOM122810